Table of Contents
TROUBLESHOOTING
Engine
Spark Plug Fouling
• Spark plug cap loose or faulty
• Incorrect spark plug heat range or gap
• PVT system calibrated incorrectly/ components
worn or mis-adjusted
• Fuel quality poor (old) or octane too high
• Low compression
• Restricted exhaust
• Weak ignition (loose coil ground, faulty coil, or
stator)
• Restricted air filter (main or pre-cleaner) or
breather system
• Improperly assembled air intake system
• Restricted engine breather system
• Oil contaminated with fuel
Engine Turns Over But Fails To Start
• No fuel
• Dirt in fuel line or filter
• Fuel will not pass through fuel valve
• Fuel pump inoperative/restricted
• Tank vent plugged or pinched
• Engine flooded
• Low compression (high cylinder leakage)
• No spark (Spark plug fouled) ignition component
failure
Engine Does Not Turn Over
• Dead battery
• Starter motor does not turn
• Engine seized, rusted, or mechanical failure
Engine Runs But Will Not Idle
• Restricted fuel supply
• Low compression
• Crankcase breather restricted
Engine Idles But Will Not Accelerate
• Spark plug fouled/weak spark
• Broken throttle cable
9925724 R01 - 2014-2015 RZR XP 1000 / RZR XP4 1000 Service Manual
Engine Has Low Power
Piston Failure - Scoring
Excessive Smoke and Carbon Buildup
Piston Failure - Scoring
Excessive Smoke and Carbon Buildup
Low Compression
© Copyright 2014 Polaris Industries Inc.
ENGINE / COOLING SYSTEM
• Obstruction in air intake
• Air box removed (reinstall all intake components)
• Incorrect ignition timing
• Restricted exhaust system
• Cam worn excessively
• Spark plug fouled
• Cylinder, piston, ring, or valve wear or damage
(check compression)
• PVT not operating properly
• Restricted exhaust muffler
• Cam worn excessively
• Lack of lubrication
• Dirt entering engine through cracks in air filter or
ducts
• Engine oil dirty or contaminated
• Excessive piston-to-cylinder clearance
• Wet sumping
• Worn rings, piston, or cylinder
• Worn valve guides or seals
• Restricted breather
• Air filter dirty or contaminated
• Lack of lubrication
• Dirt entering engine through cracks in air filter or
ducts
• Engine oil dirty or contaminated
• Excessive piston-to-cylinder clearance
• Wet sumping due to over-full crankcase
• Worn rings, piston, or cylinder
• Worn valve guides or seals
• Restricted breather
• Air filter dirty or contaminated
3
3.89
Chapters
Table of Contents
Troubleshooting
