GE Monogram ZGU48N4G Installation Instructions Manual
48" and 36" professional gas cooktops
Hide thumbs
Also See for Monogram ZGU48N4G:
- Owner's manual (28 pages) ,
- Installation instructions manual (12 pages) ,
- Owner's manual (28 pages)
Table of Contents
Quick Links
See also:
Owner's Manual
Table of Contents
Related Manuals for GE Monogram ZGU48N4G
Summary of Contents for GE Monogram ZGU48N4G
- Page 1 Installation Instructions ProfessionalGas Cooktops 48" Natural Gas Models ZGU48N4G ZGU48N6R ZGU48N6D 48" LP Gas Models ZGU48L4G ZGU48L6R ZGU48L6D 36" Natural Gas Models ZGU36N6 ZGU36N4R ZGU36N4D 36" LP Gas Models ZGU36L6 ZGU36L4R ZGU36L4D Monogram°...
- Page 2 Installation instructions BEFORE YOU BEGIN CAUTION'. THESE COOKTOPS SHOULD BE INSTALLED Read these instructions completely and IN CONJUNCTION WITH A SUITABLE carefully. OVERHEAD VENT HOOD. Due to the high heat capacity "IMPORTANT- Save these instructions for of this unit, particular attention should be paid to the local inspector's use.
-
Page 3: Table Of Contents
ZGU36N4R - 4 gas burners and grill 48" Natural Gas Models: ZGU36N6 - 6 gas burners ZGU48N4G -4 gas burners, grill and griddle 36" Liquid Propane Gas Models: ZGU48N6R -6 gas burners and grill ZGU36L4D - 4 gas burners and griddle... -
Page 4: Product Dimensions And Clearances
Design Information PRODUCT DIMENSIONS AND CLEARANCES 48" Wide Models 47 7/8 "__ 36" Min. to Combustible 8 7/16 Material From 18" Min. Cooking Allow Additional Clearance Mateda] Surface Below tile CooktopBurner Boxfor the Regulatorand GasConnections 7/8" 22-3/4" Min. 36"WideModels 8-7/16" Allow Additional Clearance Below the CooktopBurner Box for the Regulatorand... -
Page 5: Installation Options
Installation Preparation INSTALLATION OPTIONS ADVANCE PLANNING These cooktops can be installed in standard 24" or Refer to "Dimensions and Clearances" for appropriate deeper 25" cabinets. placement and necessary clearances when planning the installation. • In 24" deep cabinets, the front of the cooktop will project approximately 1-7/8"... -
Page 6: Tools And Materials Required
Installation Preparation TOOLS REQUIRED MATERIALS REQUIRED (not supplied) • Saw • Pipe and fittings as required • Measuring tape • Manual gas line shut-off valve • Carpenter's square • Gas pressure regulator (supplied) • Large flat-blade screwdriver • Gas-resistant pipe joint sealant •... -
Page 7: Step 1 Remove Packaging
Installation STEP 1 REMOVE PACKAGING Use a hand-truck to move this cooktop. • Flatten the carton and use a piece as a pad on the bottom and back of the hand-truck. Lift the cooktop onto Before moving the cooktop indoors: the hand-truck standing on its end, with the bottom of the cooktop resting against the back of the hand-truck. -
Page 8: Step 3, Install The Cooktop
Installation STEP 3 INSTALL COOKTOP • Lower the cooktop into the opening. Make sure the cooktop is evenly seated and supported, A side frame gasket will seal the cooktop to the countertop. • "L" brackets with screws are provided to secure the cooktop to the countertop or to adjacent cabinetry. -
Page 9: Step 5 Connect Electrical
Installation STEP 5 CONNECT ELECTRICAL Plug power cord into properly grounded receptacle. STEP 6 ASSEMBLE BURNERS, CHECK IGNITION Assemble burners as shown. Checkto be sure that burner heads and caps are securely seated. Pin(s) must completely engage holes to ensure proper assembly. _J BurnerCap BurnerHead -_ •... -
Page 10: Finalize Installation
Installation FINALIZE INSTALLATION Place the burner grates over the burners. Press corner The griddle has two leveling screws beneath the rear of the grate to the coolPage 11: Install The Cooktop Backsplash Accessory
Installation iNSTALL 9" or 12" HiGH BACKSPLASH Slotsfor Vertical \ Adjustment • Install and level the range or cool{top according to the Backsection installation instructions. Remove the backsplash packaging. Select the back, wall mount panel with mounting screw slots. 1/8t Marl{ a horizontal line on the wall, 1/8"...- Page 12 Producl improx(m( is a conlinuing endeavor General Ele(tric. Thereilnx, malerials, app(aran(_ spetif]calions sul?ject to chmlg( wilhotlr notic(. Monogram: GE Consumer & I/Idustria/ Pub.No. 49-80225-3 GE Appliancos Gono_l FIoc_c _nlpang PartNo. 164D4290P377 Louisville, KY40225 17713Rev.C go con) ©2006 GE Company 12-06JR...