Page 1
RC5MDTS2 P1331427M RC5MDTM2 P1331428M RC520T2 P1331423M • Due to possibility of personal injury or property damage, always contact an authorized technician for servicing or repair of this unit. • Refer to Service Manual 16022149 for installation, operating, testing, troubleshooting, and disassembly instruction.
Component Testing Procedures WARNING To avoid risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitor before servicing, unless testing requires power. Illustration Component Test Results Thermal cutout Disconnect all wires from TCO. Measure resistance across terminals. Magnetron TCO ........
Page 3
Component Testing Procedures WARNING To avoid risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitor before servicing, unless testing requires power. Illustration Component Test Results Transformer Discharge Capacitor Remove all wires from terminals. Measure resistance from: Less than 1 Ω...
Page 4
Component Testing Procedures WARNING To avoid risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitor before servicing, unless testing requires power. Illustration Component Test Results Continuity is indicated as 100 Ω and Side touch panel Trace Measurement 3 &...
Page 5
Component Testing Procedures WARNING To avoid risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitor before servicing, unless testing requires power. H.V. board Pin 1 Pin 1 Pin 28 Pin 1 Pin 50 Pin 1 Pin 1 Pin 1 Pin 1...
Page 6
Component Testing Procedures WARNING To avoid risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitor before servicing, unless testing requires power. H.V. Board − Relay Test Three Magnetron Models Relay Function Test Set-Up Meter Probe Placement Results Setting...
Page 7
Component Testing Procedures WARNING To avoid risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitor before servicing, unless testing requires power. Three Magnetron Models H.V. System # 1 H.V. System # 2 H.V. System # 3 Top Rear Magnetron Top Front Magnetron Bottom Magnetron...
All Amana and Menumaster microwave oven power outputs are rated using the IEC705 standards. Using the IEC705 test method requires precision measurements and equipment that is not practical to be performed in the field. Using the test shown below will indicate if the oven performance is satisfactory.
Diagnostics Procedures WARNING To avoid risk of electrical shock, personal injury or death; disconnect power to oven and discharge capacitor before servicing, unless testing requires power. CAUTION All repairs as described in this troubleshooting section are to be performed only after the caution procedures one through eight listed below have been followed.
Service Test NOTE: Unit must be in OFF condition INITIAL power up mode. To Enter Service Test Mode, oven door must be closed. NOTE: Pads will not beep when accessing Service Test Mode. To EXIT Service Test Mode press STOP/RESET pad. MC units REG MENU MISC...
Page 11
Service Test This mode is NOT active with these models. NOT ACTIVE PREHEAT READY STANDBY LEVEL If no fan operation, check: Blower motor and wheel Antenna motor Cavity light (if applicable) PREHEAT READY STANDBY LEVEL H.V. board relay K1 - 230 V relay K2 - 208V Wiring This mode is NOT active...