Table of Contents
Table of contents
Table of contents
1.1
About this document..................................................................
2.1
Outdoor unit...............................................................................
2.1.1
To handle the outdoor unit ..........................................
2.1.2
3.1
Possible system layouts ............................................................
3.1.1
Dedicated gas boiler ...................................................
3.1.2
Third-party gas boiler ..................................................
3.2
Freeze protection ......................................................................
3.2.1
Glycol or freeze protection valves...............................
3.2.2
Bottom plate heater.....................................................
4.1
Preparing the installation site ....................................................
4.1.1
4.1.2
outdoor unit in cold climates .......................................
4.2
Preparing water piping ..............................................................
4.2.1
Water piping lengths and height difference ................
4.2.2
To check the water volume and flow rate ...................
4.3
Preparing electrical wiring .........................................................
4.3.1
internal actuators ........................................................
5.1
Opening the units ...................................................................... 10
5.1.1
To open the outdoor unit............................................. 10
5.2
Mounting the outdoor unit.......................................................... 10
5.2.1
To provide the installation structure ............................ 10
5.2.2
To install the outdoor unit............................................ 11
5.2.3
To provide drainage .................................................... 11
5.2.4
To prevent the outdoor unit from falling over .............. 12
5.3
Connecting water piping............................................................ 12
5.3.1
To connect the water piping........................................ 12
5.3.2
5.3.3
To protect the water circuit against freezing ............... 13
5.3.4
To fill the space heating circuit.................................... 15
5.3.5
To fill the domestic hot water tank .............................. 16
5.3.6
To insulate the water piping ........................................ 16
5.4
Connecting the electrical wiring................................................. 16
5.4.1
In case of dedicated gas boiler ................................... 16
5.4.2
In case of third-party gas boiler................................... 18
6.1
Overview: Configuration ............................................................ 20
6.1.1
To access the most used commands ......................... 21
6.2
Basic configuration .................................................................... 21
6.2.1
Quick wizard: Language / time and date..................... 21
6.2.2
Quick wizard: Standard............................................... 21
6.2.3
Quick wizard: Options ................................................. 22
6.2.4
Space heating control ................................................. 23
6.2.5
Domestic hot water control ......................................... 24
6.2.6
Contact/helpdesk number ........................................... 25
6.3
Advanced configuration/optimization......................................... 25
6.3.1
Heat source settings ................................................... 25
6.4
Menu structure: Overview installer settings............................... 26
7.1
Checklist before commissioning................................................ 27
7.2
Checklist during commissioning ................................................ 27
7.2.1
To perform an air purge .............................................. 28
7.2.2
To perform a test run .................................................. 28
7.2.3
To perform an actuator test run .................................. 28
Installation manual
4
7.2.4
To perform an underfloor heating screed dryout.......... 28
4
9.1
Piping diagram: Outdoor unit...................................................... 29
9.2
Wiring diagram: Outdoor unit ..................................................... 30
4
5
5
1
About the documentation
5
5
1.1
About this document
5
5
WARNING
5
This appliance is not intended for use by persons,
6
including children, with reduced physical, sensory or
6
mental capabilities, or lack of experience and knowledge,
7
unless they have been given supervision or instruction
7
concerning use of the appliance by a person responsible
7
for their safety.
7
Children should be supervised to ensure that they do not
7
play with the appliance.
Cleaning and user maintenance must not be carried out by
7
children without supervision.
8
8
Target audience
9
Authorised installers
9
Documentation set
9
This document is part of a documentation set. The complete set
10
consists of:
▪ General safety precautions:
▪ Safety instructions that you must read before installing
▪ Format: Paper (in the box of the outdoor unit)
▪ Operation manual:
▪ Quick guide for basic usage
▪ Format: Paper (in the box of the outdoor unit)
▪ User reference guide:
▪ Detailed step-by-step instructions and background information
for basic and advanced usage
▪ Format: Digital files on
and-manuals/product-information/
▪ Installation manual - Heat pump module:
▪ Installation instructions
▪ Format: Paper (in the box of the outdoor unit)
20
▪ Installation and operation manual - Gas boiler module:
▪ Installation and operation instructions
▪ Format: Paper (in the box of the gas boiler)
▪ Installer reference guide:
▪ Preparation of the installation, good practices, reference data,...
▪ Format: Digital files on
and-manuals/product-information/
▪ Addendum book for optional equipment:
▪ Additional info about how to install optional equipment
▪ Format: Paper (in the box of the outdoor unit) + Digital files on
27
http://www.daikineurope.com/support-and-manuals/product-
information/
Latest revisions of the supplied documentation may be available on
the regional Daikin website or via your dealer.
http://www.daikineurope.com/support-
http://www.daikineurope.com/support-
EJHA04AAV3
Daikin Altherma H Hybrid - Heat pump module
4P530607-1D - 2020.02
29
29
Table of Contents
