Sealey CRM251 Instructions

Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these

instructions, and properly maintained, give you years of trouble free performance.

IMPORTANT: PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE

THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR

PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.

Refer to

Electrical

instructions

shock

hazard

1. SAFETY

1.1.

Electrical Safety

WARNING! It is the user's responsibility to check the following:

‰

Check all electrical equipment and appliances to ensure that they are safe before using. Inspect power supply leads, plugs and

all electrical connections for wear and damage. Sealey recommend that an RCD (Residual Current Device) is used with all electrical

products. You may obtain an RCD by contacting your local Sealey dealer.

If used in the course of business duties, it must be maintained in a safe condition and routinely PAT (Portable Appliance Test) tested.

Electrical safety information, it is important that the following information is read and understood.

Ensure that the insulation on all cables and on the appliance is safe before connecting it to the power supply.

9

regularly inspect power supply cables and plugs for wear or damage and check all connections to ensure that they are secure.

9

Ensure that the voltage rating on the appliance suits the power supply to be used and that the plug is fitted with the correct fuse - see

9

fuse rating in these instructions.

DO NOT pull or carry the appliance by the power cable.

8

DO NOT pull the plug from the socket by the cable.

8

DO NOT use worn or damaged cables, plugs or connectors. Ensure that any faulty item is repaired or replaced immediately by a

8

qualified electrician.

This product is fitted with a BS1363/A 13 Amp 3 pin plug.

9

If the cable or plug is damaged during use, switch off the electricity supply and remove from use.

Ensure that repairs are carried out by a qualified electrician.

Replace a damaged plug with a BS1363/A 13 Amp 3 pin plug. If in doubt contact a qualified electrician.

a) Connect the GREEN/YELLOW earth wire to the earth terminal 'E'.

b) Connect the BROWN live wire to the live terminal 'L'.

c) Connect the BLUE neutral wire to the neutral terminal 'N'.

Ensure that the cable outer sheath extends inside the cable restraint and that the restraint is tight.

Sealey recommend that repairs are carried out by a qualified electrician.

1.2.

General Safety

Familiarise yourself with the application and limitations of the reel, as well as the specific hazards.

WARNING! Isolate the reel from the electrical supply before connecting or disconnecting

‰

equipment, servicing or performing any maintenance.

Maintain the reel in good condition (use an authorised service agent).

9

Replace or repair damaged parts. Use recommended parts only. Unauthorised parts may be dangerous and will invalidate the

9

warranty.

Locate and fix the reel in a suitable work area. DO NOT position in direct sunlight, or in areas of extreme temperature.

9

Keep extended cable away from heat, oil and sharp edges. Check cable for wear before each use and ensure all connections are

9

secure.

Maintain correct balance and footing. Ensure the floor is not slippery and wear non-slip shoes.

9

Keep children and unauthorised persons away from the work area.

9

DO NOT allow the extended cable to trail through liquids.

8

DO NOT trail the extended cable where it is likely to be a hazard to others.

8

DO NOT allow vehicles or wheeled equipment to pass over the extended cable.

8

DO NOT use the reel for any purpose other than that for which it is designed.

8

DO NOT operate the reel when you are tired, under the influence of alcohol, drugs or intoxicating medication.

8

When not in use, switch off the electrical supply and retract cable into case. Store in a safe, dry location

9

WARNING! DO NOT dismantle the reel casing, or attempt to remove the screws on the sides. To do so may result in damage to the

‰

reel and/or personal injury and will invalidate the warranty. Internal maintenance, which will require the opening of the casing, must

only be undertaken by an authorised service agent.

WARNING! Observe the wound and unwound capacities in the specifications below.

‰

© Jack Sealey Limited

INSTRUCTIONS FOR

CABLE REEL SYSTEM RETRACTABLE 25mtr

1 X 230V SOCKET.

CRM251

MODEL NO:

Original Language Version

Recommended fuse rating

13 Amp

CRM251 | Issue 2 20/07/17