Sony SIU-100 Service Manual
  1. Manuals
  2. Brands
  3. Sony Manuals
  4. Recording Equipment
  5. SIU-100
  6. Service manual

Sony SIU-100 Service Manual

System interface unit, 8ch mic pre amp board, remote control unit
Hide thumbs Also See for SIU-100:
Table of Contents

Quick Links

SYSTEM INTERFACE UNIT
SIU-100
SIU-100T
8CH MIC PRE AMP BOARD
DMBK-S101
REMOTE CONTROL UNIT
SIU-RM101
SERVICE MANUAL
1st Edition
Table of Contents
loading

Related Manuals for Sony SIU-100

Summary of Contents for Sony SIU-100

  • Page 1 SYSTEM INTERFACE UNIT SIU-100 SIU-100T 8CH MIC PRE AMP BOARD DMBK-S101 REMOTE CONTROL UNIT SIU-RM101 SERVICE MANUAL 1st Edition...
  • Page 2 électrique, d’incendie ou de blessure n’effectuer que les réparations indiquées dans le mode d’emploi à moins d’être qualifié pour en effectuer d’autres. Pour toute réparation faire appel à une personne compétente uniquement. SIU-100 (SY) Serial No. 800001 and Higher SIU-100T (SY) Serial No.
  • Page 3 For SIU-100/100T For SIU-100/100T Attention-when the product is installed in Rack: When using a LAN cable: For safety, do not connect to the connector for peripheral 1. Prevention against overloading of branch circuit device wiring that might have excessive voltage.
  • Page 4 For SIU-100/100T CAUTION ADVARSEL Danger of explosion if battery is incorrectly replaced. Lithiumbatteri - Eksplosjonsfare. Ved utskifting benyttes kun batteri som anbefalt av apparatfabrikanten. Replace only with the same or equivalent type recommended by the manufacturer. Brukt batteri returneres Dispose of used batteries according to the apparatleverandøren.

  • Page 5: Table Of Contents

    1-6. Upgrading Firmware ................. 1-28 1-7. Using the Extension Board ................ 1-30 1-8. Self-Diagnosis ................... 1-31 1-8-1. SIU-100/100T ................1-31 1-8-2. SIU-RM101 ................1-32 1-9. Forming the Flexible Card Wire ............... 1-34 2. Electrical Alignment 2-1. Equipment required ..................2-1 2-2.
  • Page 6 3. Spare Parts 3-1. Notes on Repair Parts .................. 3-1 3-2. Exploded Views and Parts List ..............3-2 3-2-1. SIU-100/100T ................3-2 3-2-2. SIU-RM101 ................3-4 3-3. Electrical Parts List ..................3-5 3-3-1. SIU-100/100T ................3-5 3-3-2. DMBK-S101 ................3-17 3-3-3.
  • Page 7 6. Board Layouts 6-1. SIU-100/100T ..................... 6-2 CP-383 ......................6-2 CPU-353 ...................... 6-4 IF-895 ......................6-6 HP-113 ......................6-7 LED-399 ...................... 6-7 LED-400 ...................... 6-7 MB-983 ....................... 6-8 6-2. DMBK-S101 ..................... 6-10 ADC-46 ..................... 6-10 6-3. SIU-RM101 ....................6-12 CN-2363 ....................6-12 CPU-354 ....................

  • Page 9: Manual Structure

    Manual Structure Purpose of this manual This manual is the service manual of the system interface unit SIU-100 series (following models). SIU-100, SIU-100T, DMBK-S101, SIU-RM101. This manual is intended for use by trained system and service engineers, and provides the information of maintenance and detailed service.

  • Page 10: Contents

    . ADAT is the registered trademark of the interface of ALESIS STUDIO ELECTRONICS, INC. . TDIF is the trademark of the interface of TEAC Corporation. . Unless otherwise specified, all names of companies and products are trademarks or registered trademarks of the respective companies. SIU-100/100T...

  • Page 11: Service Overview

    In addition, keep sufficient space around the SIU-100/100T to allow ventilation and heat dissipation to the environment. . When installing the SIU-100/100T to the rack, keep sufficient space around the SIU-100/100T so that the ambient temperature inside the rack is 35 dC or less.
  • Page 12 4. Recommended Power Cord (SIU-100/100T) This unit does not come with a power cord. To get a power cord, please contact your local Sony Sales Office/Service Center. . Use the approved Power Cord (3-core mains lead)/ Appliance Connector/Plug with earthing-contacts that conforms to the safety regulations of each country if applicable.

  • Page 13: Installation Space

    1-1-3. Installation Space The following shows the external dimension of SIU-100/100T. Unit : mm SIU-100/100T...
  • Page 14 The following shows the external dimension of SIU-RM101. 66.8 14.2 Unit : mm SIU-100/100T...

  • Page 15: Connectors And Cables For Connection

    1-1-4. Connectors and Cables for Connection Use the connector and the cable below or the eguivalent at the tip when cables are connected to each connector on the connector panel, during installation and service. 1. SIU-100/100T Connector on SIU-100 side Connector Adaptive connector/cable Panel display...
  • Page 16 7. DMBK-R106 Connector on DMBK-R106 side Connector Adaptive connector/cable Panel display Name Name Sony Part No. NTERFACE BORD FOR ADAT Square type-optical connector EIAJ Fiber optic cable (TOSLINK) 8-749-016-70 (DI) DO1-8, DI1-8 8-749-016-71 (DO) 8. DMBK-R107 Connector on DMBK-R107 side...

  • Page 17: Input/Output Signals Of Connectors

    Signal level : Sony 9-pin standard Input and output signals of each connector on the - Outside view - SIU-100/100T and optional boards are shown as below. 1. SIU-100/100T Control signal input/output REF WORD/VODEO IN : BNC (AUTO 75 Z terminated) REMOTE IN .
  • Page 18 Signal level : conform to TDIF interface standard MIDI IN : DIN 5P, Female - Outside view - Same as the SIU-100/100T MIDI IN connector REMOTE IN : D-sub 9P, Female Same as the SIU-100/100T REMOTE IN connector Pin No.

  • Page 19: Switch/Short-Pin Setting And Led Functions

    Functions D500, 501, 502, 503 : CPU operation check If CPU starts up after the power is turned on, the initial- 1. SIU-100/100T ization is completed and the normal operation starts, four . CPU-353 board LEDs light on in order indicating that CPU is operating.
  • Page 20 Light on : Lock the AES/EBU DI ch7/8 PLL circuit Light on : Lock the AES/EBU DI ch7/8 PLL circuit Light off : Unlock the AES/EBU DI ch7/8 PLL circuit Light off : Unlock the AES/EBU DI ch7/8 PLL circuit 1-10 SIU-100/100T...
  • Page 21 Light on : Lock the ADAT DI ch1-8 PLL circuit Light on : Lock the TDIF-1 DI ch1/2 PLL circuit Light on : Unlock the ADAT DI ch1-8 PLL circuit Light off : Unlock the TDIF-1 DI ch1/2 PLL circuit 1-11 SIU-100/100T...

  • Page 22: Installation Of Optional Boards

    SLOTs 8 → 7 → 6 → 5. Digital boards : DMBK-R103/R104/R106/R107/R109 Analog boards : DMBK-R101/R102/R105/S101 . DMBK-S101 is only for SIU-100/100T, and cannot be installed to Digital Mixer DMX-R100. Option board (DMBK-R101 to R107,...

  • Page 23: Connection Of Siu-Rm101

    Multiple SIU-RM101 can be connected. 1. SIU-100/100T The connection method is as follows. SIU-100/100T can be mounted in a standard 19 inch rack. (1) Combine the attachment screws and the holes. Be sure to use the optional rack mount rail RMM-30.
  • Page 24 2 _ 7 x 10 +0.1 4 x 6 Longitudinal hole Longitudinal hole 17.5 32.5 9 Hole Cleanly side Unit : mm Example of Rack-mount Rack mount bracket Washer B5 x 8 SIU-RM101 B4 x 6 Link two sets Rack mount bracket 1-14 SIU-100/100T...

  • Page 25: Location Of The Boards

    1-2. Location of the Boards 1. SIU-100/100T IF-895 board CPU-353 board PS-640 board MB-983 board LED-399 board HP-113 board CCP-383 board Figure : SIU-100T 2. SIU-RM101 FP-137 board CN-2363 board CPU-354 board 1-15 SIU-100/100T...

  • Page 26: Removal Of Cabinet

    Each screw has a stopper. Turn the screws a few times, and BVTT Case 3 x 6 pull the front panel holding the screws to remove. BVTT 3 x 6 Screws (with stopper) BVTT 3 x 6 Screws (with stopper) Front panel assembly 1-16 SIU-100/100T...

  • Page 27: Replacement Of Main Parts

    There is the blank panel over the slot for power unit B on 1-4-1. Installing/Replacing Power Unit the SIU-100. When installing the power unit in this slot, remove the blank panel and use the same screws that secured the blank panel.
  • Page 28 If the regulation DC voltage is not achieved, this means there is a PS-640 board failure. These voltage values are the unloaded output voltages when power unit’s operation is confirmed as one unit. It differs from the voltage of the power unit installed on SIU-100. 1-18 SIU-100/100T...

  • Page 29: Removal Of If-895 Board

    (4) Remove four screws, and remove the IF-895 board CN6103 with the socket connecting plate as shown in the figure. 3 x 6 IF-895 board CN6302 CN6301 Socket connecting plate BVTT 3 x 6 IF-895 board Socket connecting plate BVTT 3 x 6 1-19 SIU-100/100T...

  • Page 30: Removal Of Fan

    Fan mounting plate 3 x 30 3 x 30 DC fan(92 square) B3 x 30 Attach the fan in the reverse order of steps (1) to (6). Attach the fan in the reverse order of steps (1) to (2). 1-20 SIU-100/100T...

  • Page 31: Replacement Of Lithium Battery

    (“Storing the current operation settings in non-volatile memory as backup data” in the Menu Operation section of the Operation Manual.) If the above step (1) is not performed, the operational state will be lost when the battery is removed. 1-21 SIU-100/100T...

  • Page 32: Notes For The Cpu-353 Board Replacement

    1-5. Notes for the CPU-353 Board Replacement The built-in FTP server of the SIU-100/100T only has a function to transfer a certain data (such as version up and 1-5-1. Replacing/Restoring Data data backup). Also, it only supports the commands de- scribed.
  • Page 33 (2) Press → to display the IP sub menu. required. (3) While pressing ↓, display each of the following (h) Upload the data file from the PC to the SIU-100/100T. (i) Store the uploaded data onto Flash Memory. three items to change the value. (Or, write down (j) Execute SYSTEM RESTORE.
  • Page 34 (c) Download the data from the SIU-100/100T with the (d) Remove the old CPU-353 board from SIU-100/ old CPU-353 board to a PC and save as a file 100T. (Ensure the SIU-100/100T power is first (1) Connect the SIU-100/100T to a PC through the switched OFF.)
  • Page 35 By this operation, the data is tentatively trans- (h) Upload the data file from the PC to the SIU-100/ ferred to the SRAM on the CPU-353 board of the 100T with the new CPU-353 board.
  • Page 36 When Upall is selected, both scene and SYSTEM (6) The serial number is written in the Flash Memory BACKUP data are restored. of the CPU, and the SIU-100/100T automatically Do not use Upsram or Upscene unless there are restarts. special circumstances. (Upsram restores only SYSTEM BACKUP data.

  • Page 37: Testing The Cpu-353 Board

    This formats the memory contents of the CPU-353 board to the factory-setting status. If an upgrade fails and the SIU-100/100T does not start Please note that this operation will format scene data in normally, start by the factory-setting version to upgrade Flash Memory and user status data in SRAM.

  • Page 38: Upgrading Firmware

    (b) Prepare the upgrading file on the PC. File size = 1572864 bytes (c) Upload the data file from the PC to the SIU-100/100T. (d) Save the uploaded file data into the Flash Memory (c) Uploading the data file from the PC to the SIU-100/ using the browser.
  • Page 39 (3) Start the FTP to transfer the file to the SIU-100. (d) Saving the uploaded file data into the Flash Memo- (See the image below) ry using the browser (3-1) Move to the folder that stores t00.bin. The Using the Web browser (such as Internet Explorer), following example shows C:\WINDOWS.

  • Page 40: Using The Extension Board

    (f) Confirm the version Extension board EX-897 : Part No. A-8347-460-A (1) Power off the SIU-100. (2) Turn on the power of the SIU-100 while pressing Extension board EX-729 the CHECK button on the panel. Keep pressing Extension board uses that performs for the maintenance the CHECK button until the version is displayed.

  • Page 41: Self-Diagnosis

    1-8. Self-Diagnosis Using the extension board 1-8-1. SIU-100/100T When attaching or removing the extension board, make sure that unit’s power is turned off. The operation checks for the CP-383 and LED-399 boards (1) Remove the desired optional board from it’s slot, then...

  • Page 42: Siu-Rm101

    The LED of D2473 (STATUS), D2474 (METER) light in green and not light in red. Confirm that the LEDs light as follows: LOCK OVER Orange LEVEL Green /SIGNAL SLOTs 1 to 8 Orange +48V Orange CHANNEL Green Green 1-32 SIU-100/100T...
  • Page 43 E) Turn each LEVEL control to +, and confirm that is displayed in each LEVEL window. F) Turn each LEVEL control to _, and confirm that is displayed in each LEVEL window. G) The KEY test is completed. 1-33 SIU-100/100T...

  • Page 44: Forming The Flexible Card Wire

    Conductive surface (Silver) 25 mm CPU-354 (CN501) 25 mm 34 mm Insulated surface (Blue) 20 mm 20 mm 10 mm 20 mm CN-2363 (CN102) Conductive surface (Silver) Unit : mm 34 mm FP-137 (CN601) Conductive surface (Silver) Unit : mm 1-34 SIU-100/100T...

  • Page 45: Electrical Alignment

    Adjustment required board name Contents CPU-353 Video PLL free-run frequency adjustment : RV1300, RV1301, RV1302 2-1. Equipment required Name Principal specifications Equipment name Frequency counter Efficiency digit : More than 5digits HEWLETT PACKRD 5315A or equivalent Adjusting driver SIU-100/100T...

  • Page 46: Board (Video Pll Free-Run Frequency Adjustment )

    48, 96 1RV1301 4.7952 ± 0.00004 MHz 47.952 1RV1302 * : When adjust by the Fs settings of 44.1 kHz and 48 kHz, there are no necessity for adjustment by the Fs settings of 88.2 kHz and 96 kHz. SIU-100/100T...

  • Page 47: Spare Parts

    Therefore, specified parts should be used in the case of replacement. 2. Standardization of Parts Some repair parts supplied by Sony differ from those used for the unit. These are because of parts common- ality and improvement. Parts list has the present standardized repair parts.

  • Page 48: Exploded Views And Parts List

    Front 3-2. Exploded Views and Parts List BVTT 3 x 6 3-2-1. SIU-100/100T BVTT 3 x 6 K3 x 6 BVTT 3 x 6 3 x 6 3 x 6 3 x 30 B3 x 6 3 x 6 K3 x 6...
  • Page 49 7-682-548-09 s SCREW +B3X8 1-773-032-11 s WIRE (FLAT TYPE) (15 CORE) 7-682-555-04 s SCREW +B3X30 1-773-413-11 s WIRE (FLAT TYPE) (35 CORE) 7-682-947-01 s SCREW +PSW3X6 2-068-008-00 s WASHER 7-685-646-79 s SCREW +BVTP3X8 2-990-241-02 s HOLDER (A), PLUG 7-685-871-01 s SCREW,+BVTT3X6 SIU-100/100T...

  • Page 50: Siu-Rm101

    1-783-282-14 s CABLE, FLEXIBLE FLAT (50 CORE) 7-621-759-40 s SCREW +PSW2.6X6(EP-FE/ZNBK/CM 2-270-601-00 o SUPPORT 7-621-773-95 s SCREW +B2.6X6(EP-FE/ZNBK/CM2) 3-180-315-21 s BODY, KNOB 7-682-147-09 s SCREW +P3X6 (EP-FE/ZNBK/CM2) 3-613-164-11 o SHAFT, STEP 7-682-545-04 s SCREW +B3X4 3-624-733-51 s DIA10CAP 7-682-947-01 s SCREW +PSW3X6 3-624-750-01 s KEYTOP(B) SIU-100/100T...

  • Page 51: Electrical Parts List

    3-3. Electrical Parts List 3-3-1. SIU-100/100T ------------ CP-383 BOARD (CP-383 BOARD) ------------ Ref. No. Ref. No. or Q'ty Part No. SP Description or Q'ty Part No. SP Description A-8346-007-A s MOUNTED CIRCUIT BOARD, CP-383 C2354 1-128-590-11 s CAPACITOR ELECT 1000MF/6.3V...
  • Page 52 1-762-060-11 s SWITCH, KEY R2111 1-218-263-11 s RESISTOR,CHIP 75 1/2W (4532) R2112 1-218-263-11 s RESISTOR,CHIP 75 1/2W (4532) S2218 1-762-060-11 s SWITCH, KEY S2219 1-762-060-11 s SWITCH, KEY R2113 1-218-263-11 s RESISTOR,CHIP 75 1/2W (4532) S2220 1-762-060-11 s SWITCH, KEY SIU-100/100T...
  • Page 53 1-164-156-11 s CAPACITOR,CERAMIC 0.1MF/25V F C408 1-164-156-11 s CAPACITOR,CERAMIC 0.1MF/25V F C409 1-164-156-11 s CAPACITOR,CERAMIC 0.1MF/25V F C410 1-164-156-11 s CAPACITOR,CERAMIC 0.1MF/25V F C411 1-164-156-11 s CAPACITOR,CERAMIC 0.1MF/25V F C412 1-164-156-11 s CAPACITOR,CERAMIC 0.1MF/25V F C413 1-115-416-11 s CAPACITOR,CERAMIC 1000PF/25V SIU-100/100T...
  • Page 54 1-115-416-11 s CAPACITOR,CERAMIC 1000PF/25V C735 1-164-156-11 s CAPACITOR,CERAMIC 0.1MF/25V F C1114 1-164-156-11 s CAPACITOR,CERAMIC 0.1MF/25V F C736 1-164-156-11 s CAPACITOR,CERAMIC 0.1MF/25V F C1115 1-115-416-11 s CAPACITOR,CERAMIC 1000PF/25V C737 1-164-156-11 s CAPACITOR,CERAMIC 0.1MF/25V F C1116 1-107-826-11 s CAPACITOR,CHIP CERAMIC 0.1MF SIU-100/100T...
  • Page 55 C1351 1-162-925-11 s CAPACITOR,CERAMIC 68PF/50V CH D1103 8-719-988-61 s DIODE 1SS355TE-17 C1352 1-115-416-11 s CAPACITOR,CERAMIC 1000PF/25V C1353 1-125-837-91 s C-CAP,U 1-6.3 K B D1300 8-719-420-90 s DIODE MA8051-M C1354 1-162-927-11 s CAPACITOR,CERAMIC 100PF/50V CH D1301 8-719-988-61 s DIODE 1SS355TE-17 SIU-100/100T...
  • Page 56 1-412-525-31 s MICRO INDUCTOR 10UH IC1301 8-759-446-75 s IC TA79L09F (TE12L) L1301 1-410-369-11 s INDUCTOR,CHIP 1UH (3225) IC1302 8-759-908-92 s IC TL084CNS L1302 1-410-369-11 s INDUCTOR,CHIP 1UH (3225) IC1303 8-759-700-78 s IC NJM082M L1303 1-412-939-11 s INDUCTOR 1.0UH (2520) 3-10 SIU-100/100T...
  • Page 57 1-218-843-11 s RESISTOR,CHIP 680 1/10W (1608) R1120 1-218-880-11 s RESISTOR,CHIP 24K 1/10W (1608) R506 1-218-871-11 s RESISTOR,CHIP 10K 1/10W (1608) R1121 1-216-849-11 s RESISTOR,CHIP 220K 1/16W 1608 R507 1-216-833-11 s RESISTOR,CHIP 10K 1/10W (1608) R1122 1-216-851-11 s RESISTOR,CHIP 330K 1/16W 1608 3-11 SIU-100/100T...
  • Page 58 1-233-575-11 s RES, CHIP NETWORK 22 R1355 1-216-809-11 s RESISTOR,CHIP 100 1/10W 1608 R1356 1-216-809-11 s RESISTOR,CHIP 100 1/10W 1608 RB116 1-233-575-11 s RES, CHIP NETWORK 22 R1357 1-216-809-11 s RESISTOR,CHIP 100 1/10W 1608 RB117 1-233-575-11 s RES, CHIP NETWORK 22 3-12 SIU-100/100T...
  • Page 59 1-233-576-11 s RESISTOR,CHIP NETWORK 100 RB1006 1-233-412-11 s RESISTOR,CHIP NETWORK 1K RB1007 1-233-576-11 s RESISTOR,CHIP NETWORK 100 RB1008 1-233-412-11 s RESISTOR,CHIP NETWORK 1K RB1009 1-233-576-11 s RESISTOR,CHIP NETWORK 100 RB1010 1-233-412-11 s RESISTOR,CHIP NETWORK 1K RB1011 1-233-576-11 s RESISTOR,CHIP NETWORK 100 3-13 SIU-100/100T...
  • Page 60 L6101 1-412-549-31 s INDUCTOR,MICRO 1.0MH R6001 1-218-841-11 s RESISTOR,CHIP 560 1/10W (1608) R6002 1-218-860-11 s RESISTOR,CHIP 3.6K 1/10W(1608) R6003 1-218-871-11 s RESISTOR,CHIP 10K 1/10W (1608) R6004 1-211-985-11 s RESISTOR,CHIP 47 1/10W (1608) R6005 1-218-857-11 s RESISTOR,CHIP 2.7K 1/10W(1608) 3-14 SIU-100/100T...
  • Page 61 8-719-045-51 s DIODE SEC2422C D2449 8-719-045-51 s DIODE SEC2422C D2450 8-719-045-51 s DIODE SEC2422C D2451 8-719-045-51 s DIODE SEC2422C D2452 8-719-045-51 s DIODE SEC2422C D2453 8-719-045-51 s DIODE SEC2422C D2454 8-719-045-51 s DIODE SEC2422C D2455 8-719-045-51 s DIODE SEC2422C 3-15 SIU-100/100T...
  • Page 62 1-239-999-11 s RESISTOR, CHIP NETWORK 1.0K RB3028 1-239-999-11 s RESISTOR, CHIP NETWORK 1.0K RB3029 1-239-999-11 s RESISTOR, CHIP NETWORK 1.0K RB3030 1-239-999-11 s RESISTOR, CHIP NETWORK 1.0K RB3031 1-239-999-11 s RESISTOR, CHIP NETWORK 1.0K RB3032 1-239-999-11 s RESISTOR, CHIP NETWORK 1.0K 3-16 SIU-100/100T...

  • Page 63: Dmbk-S101

    (FERRITE CORE) 2pcs 2-527-909-00 s HANDLE,PANEL 4pcs 7-628-254-00 s SCREW +PS 2.6X5 1-771-124-21 s SWITCH, POWER 16pcs 7-685-862-09 s SCREW,+BVTT 2.6X6(EP-FE/ZNBK/C (FOR SIU-100) 2pcs 1-771-124-21 s SWITCH, POWER C100 1-125-827-11 s CAPACITOR,CERAMIC 1MF/25V (FOR SIU-100T) C101 1-125-827-11 s CAPACITOR,CERAMIC 1MF/25V...
  • Page 64 1-164-230-11 s CAPACITOR,CERAMIC 220PF/50V C224 1-162-923-11 s CAPACITOR,CERAMIC 47PF/50V CH C285 1-164-230-11 s CAPACITOR,CERAMIC 220PF/50V C225 1-104-665-11 s CAPACITOR, ELECT 100MF/25V C286 1-164-230-11 s CAPACITOR,CERAMIC 220PF/50V C226 1-162-970-11 s CAPACITOR CERAMIC 0.01MF/25V B C287 1-164-230-11 s CAPACITOR,CERAMIC 220PF/50V 3-18 SIU-100/100T...
  • Page 65 1-162-970-11 s CAPACITOR CERAMIC 0.01MF/25V B C355 1-131-679-31 s CAPACITOR,METALIZED FILM0.01MF C427 1-162-970-11 s CAPACITOR CERAMIC 0.01MF/25V B C356 1-164-156-11 s CAPACITOR,CERAMIC 0.1MF/25V F C428 1-126-022-11 s CAPACITOR,ELECT 47MF/25V (AU) C357 1-104-665-11 s CAPACITOR, ELECT 100MF/25V C429 1-104-665-11 s CAPACITOR, ELECT 100MF/25V 3-19 SIU-100/100T...
  • Page 66 1-794-099-11 s CONNECTOR, ROUND TYPE C488 1-164-230-11 s CAPACITOR,CERAMIC 220PF/50V CN400 1-794-099-11 s CONNECTOR, ROUND TYPE C500 9-910-999-34 s DELETED FROM RP MASTER CN401 1-794-099-11 s CONNECTOR, ROUND TYPE C501 1-127-573-11 s CAPACITOR,CERAMIC 1MFB(2012) CN700 1-750-795-21 s CONNECTOR, PRINT PC BOARD 3-20 SIU-100/100T...
  • Page 67 8-729-271-31 s TRANSISTOR 2SC2713-G IC206 8-759-697-17 s IC AK5383VF-E2 Q102 8-729-216-31 s TRANSISTOR 2SA1163-G IC207 6-703-235-01 s IC PGA2310UA/1K Q103 8-729-216-31 s TRANSISTOR 2SA1163-G IC300 8-759-394-76 s IC NJM2068M-D (TE2) Q104 8-729-929-08 s TRANSISTOR DTC123JE Q105 8-729-929-08 s TRANSISTOR DTC123JE 3-21 SIU-100/100T...
  • Page 68 1-216-833-11 s RESISTOR,CHIP 10K 1/10W (1608) R165 1-218-708-11 s RESISTOR,CHIP 4.7K 1/16W(1608) R104 1-216-845-11 s RESISTOR,CHIP 100K 1/10W(1608) R166 1-218-708-11 s RESISTOR,CHIP 4.7K 1/16W(1608) R167 1-218-708-11 s RESISTOR,CHIP 4.7K 1/16W(1608) R105 1-216-845-11 s RESISTOR,CHIP 100K 1/10W(1608) R168 1-218-708-11 s RESISTOR,CHIP 4.7K 1/16W(1608) 3-22 SIU-100/100T...
  • Page 69 1-218-668-11 s RESISTOR,CHIP 100 1/16W (1608) R293 1-216-825-11 s RESISTOR,CHIP 2.2K 1/10W 1608 R231 1-218-668-11 s RESISTOR,CHIP 100 1/16W (1608) R294 1-216-825-11 s RESISTOR,CHIP 2.2K 1/10W 1608 R232 1-218-700-11 s RESISTOR,CHIP 2.2K 1/16W(1608) R300 1-216-833-11 s RESISTOR,CHIP 10K 1/10W (1608) 3-23 SIU-100/100T...
  • Page 70 1-218-708-11 s RESISTOR,CHIP 4.7K 1/16W(1608) R425 1-218-718-11 s RESISTOR CHIP 12K 1/16W (1608) R362 1-218-708-11 s RESISTOR,CHIP 4.7K 1/16W(1608) R426 1-218-700-11 s RESISTOR,CHIP 2.2K 1/16W(1608) R363 1-218-708-11 s RESISTOR,CHIP 4.7K 1/16W(1608) R427 1-218-718-11 s RESISTOR CHIP 12K 1/16W (1608) 3-24 SIU-100/100T...
  • Page 71 1-218-712-11 s RESISTOR,METAL 6.8K 1/16W R488 1-216-837-11 s RESISTOR,CHIP 22K 1/16W 1608 R824 1-218-712-11 s RESISTOR,METAL 6.8K 1/16W R489 1-216-821-11 s RESISTOR,CHIP 1.0K 1/10W(1608) R825 1-218-712-11 s RESISTOR,METAL 6.8K 1/16W R490 1-216-821-11 s RESISTOR,CHIP 1.0K 1/10W(1608) R826 1-218-712-11 s RESISTOR,METAL 6.8K 1/16W 3-25 SIU-100/100T...
  • Page 72 1-755-489-11 s RELAY RY201 1-755-489-11 s RELAY RY202 1-755-489-11 s RELAY RY203 1-755-489-11 s RELAY RY300 1-755-489-11 s RELAY RY301 1-755-489-11 s RELAY RY302 1-755-489-11 s RELAY RY303 1-755-489-11 s RELAY RY400 1-755-489-11 s RELAY RY401 1-755-489-11 s RELAY 3-26 SIU-100/100T...

  • Page 73: Siu-Rm101

    1-239-896-12 s FILTER, EMI (SMD) FL206 1-239-896-12 s FILTER, EMI (SMD) FL207 1-239-896-12 s FILTER, EMI (SMD) FL208 1-239-896-12 s FILTER, EMI (SMD) FL209 1-239-896-12 s FILTER, EMI (SMD) IC100 8-759-713-45 s IC MC33166TV IC101 8-759-474-95 s IC RN5VD42AA-TL 3-27 SIU-100/100T...
  • Page 74 C431 1-162-927-11 s CAPACITOR,CERAMIC 100PF/50V CH IC503 8-759-585-99 s IC TD62783AF(S) IC504 8-759-585-99 s IC TD62783AF(S) C432 1-162-927-11 s CAPACITOR,CERAMIC 100PF/50V CH IC505 8-759-585-99 s IC TD62783AF(S) C433 1-162-927-11 s CAPACITOR,CERAMIC 100PF/50V CH IC506 8-759-524-50 s IC TC74VHC541FT(EL) 3-28 SIU-100/100T...
  • Page 75 R425 1-218-477-11 s RESISTOR CHIP 220 1/4W (3225) R326 1-211-977-11 s RESISTOR,CHIP 22 1/10W (1608) R426 1-218-477-11 s RESISTOR CHIP 220 1/4W (3225) R327 1-211-977-11 s RESISTOR,CHIP 22 1/10W (1608) R427 1-218-477-11 s RESISTOR CHIP 220 1/4W (3225) 3-29 SIU-100/100T...
  • Page 76 1-216-833-11 s RESISTOR,CHIP 10K 1/10W (1608) D618 8-719-988-61 s DIODE 1SS355TE-17 D619 8-719-988-61 s DIODE 1SS355TE-17 R555 1-216-833-11 s RESISTOR,CHIP 10K 1/10W (1608) D620 8-719-988-61 s DIODE 1SS355TE-17 X300 1-781-945-21 s VIBRATOR, CERAMIC D621 8-719-988-61 s DIODE 1SS355TE-17 D622 8-719-988-61 s DIODE 1SS355TE-17 3-30 SIU-100/100T...
  • Page 77 1-477-683-11 s ENCODER (ROTARY) EN604 1-477-683-11 s ENCODER (ROTARY) S620 1-771-908-11 s SWITCH, TACTILE S621 1-771-908-11 s SWITCH, TACTILE EN605 1-477-683-11 s ENCODER (ROTARY) S622 1-771-908-11 s SWITCH, TACTILE EN606 1-477-683-11 s ENCODER (ROTARY) S623 1-771-908-11 s SWITCH, TACTILE 3-31 SIU-100/100T...

  • Page 78: Supplied Accessories

    3-4. Supplied Accessories (FP-137 BOARD) SIU-100 Ref. No. Ref. No. or Q'ty Part No. SP Description or Q'ty Part No. SP Description S624 1-771-908-11 s SWITCH, TACTILE 4pcs 2-297-913-00 s WASHER(D1A5),ORNAMENTAL(STEEL) 2-990-242-01 s HOLDER (B),PLUG 3-613-640-01 o HOLDER (C), PLUG...
  • Page 79 In addition, for semiconductors with ID Nos., refer to the separate CD-ROM titled “Semiconductor Pin Assignments” (Sony Part No. 9-968-546-xx) that allows searching for parts by semiconductor type or ID No. The semiconductors in the manual or on the CD-ROM are listed by equivalent types.
  • Page 80 MBM29DL324BE-90PFTN ..... MBM29DL324BD-90PFTN TLC272CPSR ..............RC4558 MC33166TV ................4-5 TLC2932IPWR ............TLC2932IPW TPS54310PWPR ................ 4-6 NJM082M ................RC4558 NJM2068M-D(TE2) ............. RC4558 XC1701LPD8C ............XC1701LPD8C NJM2068M-D-TE2 .............. RC4558 XC2S150-5PQ208C1 ........XC2S150-5PQ208CES NJM78L05UA-TE1 ............. NJM78L12UA XC2S50-5TQ144C1 ..............4-5 NJM78M09DL1A(TE1) ........NJM78M12DLA_TE1 SIU-100/100T...
  • Page 81 INTERPOLATOR MODULATOR LRCK AUDIO BICK DATA INTERFACE SDTI ∆∑ AOUTR INTERPOLATOR MODULATOR VREF LA6518M-TE-R (SANYO) DUAL POWER OPERATIONAL AMPLIFIER —TOP VIEW— AMP.1 INPUT+1 OUT1 INPUT_1 THERMAL SHUTDOWN CURRENT LIMITER AMP.2 OUT1 INPUT_1 INPUT+2 OUT2 INPUT_2 INPUT+1 OUT2 INPUT+2 INPUT_2 SIU-100/100T...
  • Page 82 FILTER VCOMR CALIBRATION CONTROLLER M51954BL (MITSUBISHI) SRAM VOLTAGE DETECTION SYSTEM RESET 1, 28 MCLK —SIDE VIEW— VREFL, VREFR VOLTAGE CMODE/DFS * 2, 27 REFERENCE GNDR, GNDR * : NOTE CMODE : AK5392 : AK5393, AK5383 5 uA 1.25 V SIU-100/100T...
  • Page 83 SOURCE DONE : INPUT FOR DELAYING THE GLOBAL LOGIC INITIALIZATION & OUTPUT ENABLE /OUTPUT FOR INDICATING THE COMPLETION OF THE CONFIGURATION : TEST DATA INPUTS/OUTPUTS CCLK : CONFIGURATION CLOCK INIT : INTERNAL CONFIGURATION MEMORY CLEAR OTHER : NO CONNECTION SIU-100/100T...
  • Page 84 RISING EDGE DELAY ILIM UVLO HIGH COMP. REF/DAC HIGH ERROR OFFSET COMP. AMP. 6 - 10 DEAD TIME VSENSE OSC. 11 - 13 COMP PGND SYNC PERGD POWER GOOD COMP. AGND VSENSE FALLING EDGE DELAY 20 - 50 us SIU-100/100T...

  • Page 85: Block Diagrams

    The CPU-353 is mainly composed of the following three blocks: . CPU block: The control of overall the SIU-100/100T (The CPU is IC101 and includes the external control block.) . SYNC block: Generation of audio system clock (External and internal synchronizations) .
  • Page 86 CPU the signal including the hardware operation The SYNC block generates the audio system clock of the status. SIU-100/100T, and supplies it to the FPGA block, all . PLL dividers: option slots, and CP-383 board. Generates the timing signals as a part of the video and main PLLs.
  • Page 87 Headphone monitor output: is in operation. The headphone monitor output is sent from the CPU-353 board to the CP-383 board as the digital signal, and it receives the DA conversion on the CP-383 board to be output to the HP board. SIU-100/100T...

  • Page 88: Dmbk-S101

    . IC601, IC602: Based on the data written from the unit, performs the gain setting, PAD setting, and control of the +48 V microphone power. . IC702, IC703, IC704, IC705, IC706, IC707: Bus buffer for address and data busses. SIU-100/100T...

  • Page 89: Siu-Rm101

    MPU first displays the The CPU-354 board controls the LED lighting and recog- key operation result on the panel, and then automatically nition of key operation. switches it to the value sent from the SIU-100/100T in two SIU-100/100T...

  • Page 91: Block Diagrams

    CP-383 CP-383 5-2. Block Diagrams 5-2-1. SIU-100/100T IC2007 SCAN CLOCK GENERATOR IC2101, 2102, 2103, IC2001, CN2001 2002 2106 LED-399 CN2101 METER LED MATRIX M4A3-128/64 (PLD) MB-983 ADDRESS DECODE DINAMIC LED DISPLAY DATA HOLD SCAN LED DINAMIC SCAN TIMING GENE. DRIVER KEY READ (TIMING GENE.)
  • Page 92 BCK (64Fs) LRCK (1Fs) + 5 V + 3.3 V + 15 V _ 15 V XWORD SYNC AUDIO SIGNAL AUDIO SIGNAL AUDIO CLOCK OUTPUT INPUT/OUTPUT INPUT/OUTPUT CPU (Central processing unit) board BOARD TO BOARD CONNECTOR CN1000, 1001 CPU-353 SIU-100/100T...
  • Page 93 + 15 V MIX CN6302 CN6200 IC6101, 6201, (5P) (48P) 6104, 6204 + 5 V VOLTAGE POWER ERROR SIGNAL DROP + 15 V DETECTOR MB-983 FAN STOP _ 15 V POWER UNIT ERROR SIGNAL CN6201 AC INLET CN6103 IF-895 Interface board IF-895 SIU-100/100T...
  • Page 94 POWER SUPPLY (+ 3.3 V, + 5 V, + 15 V, _ 15 V, ) IC3001 + 9 V FAN STOP ERROR SIGNAL + 9 V CN3013 CN3018 CN3018 (35P) (15P) (15P) MB-983 CP-383 CP-383 Mother board MB-983 5-10 5-10 SIU-100/100T...

  • Page 95: Dmbk-S101

    IC601,602 +48 GENARATOR GAIN COTROL BUS BUFFER READY READY XMEMCS16 SLOTAD0 SLOTAD0 SLOTAD1 SLOTAD1 IC700 256fs CN700 MCLK 64fs CLOCK BUFFER LRCK IC701,708,709 CN700 XMUTE XMUTE PD RESET A/D converter board PD RESET/WFS MODE SET XRESET ADC-46 5-11 5-11 SIU-100/100T...

  • Page 96: Siu-Rm101

    LEDs IC305 IC309 IC500, 501, 502 IC503, 504, 505 Key Scan Address Bus / Data Bus EEPROM (LED) Driver Flip Flop (FPGA) FLEXIBLE FLAT CABLE Switches IC506 Encoders Main Dual Port Buffer Program Overall CN-2363 CPU-354 FP-137 5-12 5-12 SIU-100/100T...
  • Page 97 Index Index Section 6 Board Layouts Index SIU-100/100T Board name Circuit Function Page CP-383 Control Panel Board CPU-353 CPU (Central Processing Unit) Board HP-113 Headphones Board IF-895 Interface Board LED-399 LED Board LED-400 LED Board MB-983 Mother Board DMBK-S101 Board name...
  • Page 98 CP-383 CP-383 6-1. SIU-100/100T ———————————————————————— CP-383 (1-686-482-11,12) ———————————————————————— CN2002 CN2001 PS2004 L2003 L2002 L2001 CN2302 C2001 CL2023 * D1 D2302 R2204 * F3 CL2024 * D1 R2205 * F3 C2002 D2303 R2357 R2356 PS2003 RY2301 CL2025 * D1 D2304 R2206 * F3...
  • Page 99 CL2120 R2017 CL2119 CL2118 R2018 CL2117 CL2114 CL2116 CL2009 CL2113 CL2115 CL2112 CL2016 CL2111 CL2110 CL2106 CL2109 R2360 CL2108 D2306 R2359 CL2104 CL2107 CL2127 CL2103 CL2105 CL2102 CL2126 CL2101 CL2005 CL2100 CL2017 CL2013 CP-383 -B SIDE- SUFFIX: -11, -12 SIU-100/100T...
  • Page 100 * C5 IC1305 A2 R203 * C4 R1122 * C2 C712 C1302 D200 IC1306 A2 R204 C713 * C4 C1303 D201 IC1307 B3 R205 R1123 * C2 C714 * C4 C1304 D400 IC1308 C3 R206 * D2 R1300 * B2 SIU-100/100T...
  • Page 101 R1380 * B3 RB1004 R1400 RB1005 R1402 RB1006 R1403 RB1007 R1404 RB1008 R1405 * A4 RB1009 R1406 * A4 RB1010 R1407 * A4 RB1011 R1408 RB1012 R1409 RB1013 R1410 * B4 RB1014 R1411 * B4 RB1015 R1412 * B4 SIU-100/100T...
  • Page 102 JC6100 JC6101 L6001 L6002 L6100 L6101 R6001 * C4 R6002 * C4 R6003 * C4 R6004 * C5 R6005 * C4 R6006 R6007 R6102 * A1 R6202 * A1 TH6101 TH6301 *:B SIDE IF-895 -B SIDE- SUFFIX: -11, -12 SIU-100/100T...
  • Page 103 D2403 D2422 D2441 D2460 CL2414 * D2 D2404 D2423 D2442 D2461 CL2415 * D2 D2405 D2424 D2443 D2462 CL2416 * A2 D2406 D2425 D2444 D2463 CL2417 * B1 D2407 D2426 D2445 D2464 CL2418 * B1 D2408 D2427 D2446 D2465 SIU-100/100T...
  • Page 104 RB3022 * C1 RB3023 * C1 RB3024 * C1 RB3025 * A4 RB3026 * A4 RB3027 * A4 RB3028 * C1 RB3029 * A4 RB3030 * C1 MB-983 -A SIDE- RB3031 * C1 RB3032 * C1 SUFFIX: -11, -12 *:B SIDE SIU-100/100T...
  • Page 105 MB-983 MB-983 D3001 IC3001 RB3032 RB3031 RB3024 RB3023 RB3008 RB3007 RB3030 RB3028 RB3022 RB3020 RB3006 RB3004 RB3001 RB3003 RB3017 RB3018 RB3005 RB3019 RB3021 RB3002 RB3011 RB3009 RB3010 RB3013 RB3014 RB3016 RB3027 RB3025 MB-983 -B SIDE- SUFFIX: -11, -12 SIU-100/100T...
  • Page 106 C185 * B5 C284 * C5 C383 C482 D305 L702 * B5 * D5 * D5 * F5 C186 C285 C384 C483 D400 L703 C187 * B5 C286 * D5 C385 * F5 C484 * F5 D401 6-10 6-10 SIU-100/100T...
  • Page 107 * A4 * E4 R120 R217 R314 R411 R508 RB702 * A4 * E4 * F4 * B1 R121 R218 R315 R412 R600 RB703 R122 * B4 R219 R316 * E4 R413 * G4 R601 * C1 RB704 6-11 6-11 SIU-100/100T...
  • Page 108 R107 * A1 * A1 R108 * A1 R109 R110 * A1 R200 R201 R202 * B2 R203 * B2 R204 * B2 CN-2363 -B SIDE- * B2 R205 R206 * B2 SUFFIX: -11 R207 * B2 6-12 6-12 SIU-100/100T...
  • Page 109 FL303 FL304 R330 R535 * C2 * C2 FL305 R331 R536 CPU-354 * D1 * C2 FL306 R332 R537 -B SIDE- FL307 R333 * D1 R538 * C2 FL308 R334 * D1 R539 * C2 SUFFIX: -11 6-13 6-13 SIU-100/100T...
  • Page 110 D656 D657 D658 D659 D660 D661 D662 D663 D664 D665 D666 D667 D668 D669 D670 D671 D672 D673 EN600 EN601 EN602 EN603 EN604 EN605 EN606 EN607 ND600 ND601 FP-137 ND602 -B SIDE- ND603 ND604 SUFFIX: -11, -12 6-14 6-14 SIU-100/100T...
  • Page 111 Index Index Section 7 Schematic Diagrams Index SIU-100/100T Board name Circuit Function Page CP-383 Control Panel Board CPU-353 CPU (Central Processing Unit) Board HP-113 Headphones Board 7-25 IF-895 Interface Board 7-22 LED-399 LED Board 7-24 LED-400 LED Board 7-25 MB-983...
  • Page 112 CP-383 (1/4) CP-383 (1/4) 7-1. SIU-100/100T +3.3V C2027 0.1uF IC2006 CN2001 TC74VHC541FT(EL) CL2000 +3.3V C2026 CL2001 R2014 DAMCK 0.1uF DAMCK R2015 IC2005 DALRCK TC7SH04FU-TE85R R2016 DADATA DABCK 1.5 CL2002 R2017 R2005 R2018 CL2003 DALRCK CL2004 DADATA +3.3V XRESET XRESET IC2007...
  • Page 113 LED_SCAN[2] LED_SCAN[3] LED_SCAN[4] LED_SCAN[5] LED_SCAN[6] LED_SCAN[7] CL2128 SUFFIX:-11 D-GND 470uF/35V C2112 0.1uF C2108 100uF C2112 6.3V 0.1uF IC2106 TD62083F(S,EL) D-GND LED_SCAN[8] LED_SCAN[9] KEY_SCAN_B[3] KEY_SCAN[3] KEY_SCAN_B[2] KEY_SCAN[2] KEY_SCAN_B[1] KEY_SCAN[1] KEY_SCAN_B[0] KEY_SCAN[0] D-GND CP-383 (2/4) BOARD NO. 1-686-482-11, 12 SIU-100/100T SIU-100_CP-383_006_2 SIU-100/100T...
  • Page 114 TC74VHC541FT(EL) KD[0] KD[1] KD[2] KD[3] KD[4] KD[5] KD[6] KD[7] C2208 C2201 C2202 C2203 C2204 C2205 C2206 C2207 220pF 220pF 220pF 220pF 220pF 220pF 220pF 220pF LED_KEY KEY_SCAN[0] KEY_SCAN[1] KEY_SCAN[2] KEY_SCAN[3] CP-383 (3/4) XKEYOE BOARD NO. 1-686-482-11, 12 SIU-100/100T SIU-100_CP-383_006_3 SIU-100/100T...
  • Page 115 Q2302 D2308 2SC3617-T1TL R2364 MA132WK-TX IC2302 100k LA6518M-TE-R A-GND (2/2) R2350 -15V RY2301 R2343 4.7k 4 2 5 7 C2347 0.1uF A-GND A-GND C2348 22uF A-GND A-GND Q2300 2SC4617TL-QR A-GND -15V CP-383 (4/4) BOARD NO. 1-686-482-11, 12 SIU-100/100T SIU-100_CP-383_006_4 SIU-100/100T...
  • Page 116 RB132 30MHz A[4] D[30] CKIO RB124 CONT D[31] A[3] A[2] A[1] RB105 CPU-353 (1/14) A[0] C100 100uF BOARD NO. 1-686-477-11, 12 C107 100uF SIU-100/100T C110 C112 C113 C115 C117 C118 C120 SIU-100_CPU-353_003_1 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF SIU-100/100T...
  • Page 117 XWE[3] R200 R203 BYTE BYTE R204 R201 WP/ACC WP/ACC BT201 XRES XRES R202 RESET RESET RY/BY RY/BY VSS1 VSS2 VSS1 VSS2 C200 C201 C202 C203 0.1uF 0.1uF 0.1uF 22uF 6.3V TP200 CPU-353 (2/14) BOARD NO. 1-686-477-11, 12 SIU-100/100T SIU-100_CPU-353_003_2 SIU-100/100T...
  • Page 118 XCAS/XOE D[11] DQ11 XRAS D[10] DQ10 XCS[2] D[9] RD/XWR D[8] D[7] CKIO_0 D[6] D[5] D[4] D[3] D[2] D[1] D[0] C300 C301 C303 C305 C302 C304 100uF 100uF 0.1uF 0.1uF 0.1uF 0.1uF CPU-353 (3/14) BOARD NO. 1-686-477-11, 12 SIU-100/100T SIU-100_CPU-353_003_3 SIU-100/100T...
  • Page 119 2.2uF R402 0.001uF 0.1uF C415 C407 0.01uF 0.1uF R403 CN400 R404 TXD+ TXD- C408 0.1uF RXD+ R412 R419 TXD_CT RXD- R416 R414 RXD_CT C410 0.1uF C412 C411 0.1uF 0.1uF 9 10 CPU-353 (4/14) BOARD NO. 1-686-477-11, 12 SIU-100/100T SIU-100_CPU-353_003_4 SIU-100/100T...
  • Page 120 XPWR0-15_ALM BD[3] BD[3] XPWR1+5_ALM BD[4] BD[4] SLOTSEL[4] SLOTSEL[5] XPWR1+3_ALM BD[5] BD[5] SLOTSEL[6] XPWR1+15_ALM BD[6] BD[6] SLOTSEL[7] XPWR1-15_ALM BD[7] BD[7] XSLOTWR RB509 CPU-353 (5/14) XPOWER_CS IC507 BOARD NO. 1-686-477-11, 12 IC504 IC506 XBRD SN74LVC138APWR-12 SN74LVC540APWR SN74LVC374APWR SIU-100/100T SIU-100_CPU-353_003_5 7-10 7-10 SIU-100/100T...
  • Page 121 R604 R608 INB+ OUTB D601 INB- R610 1SS362-TE85L 3.3k INC+ OUTC D603 INC- 1SS362-TE85L FL604 IND+ OUTD IND- C601 C605 0.1uF 100uF D602 C602 1SS362-TE85L 0.1uF D604 FL605 1SS362-TE85L CPU-353 (6/14) BOARD NO. 1-686-477-11, 12 SIU-100/100T SIU-100_CPU-353_003_6 7-11 7-11 SIU-100/100T...
  • Page 122 0.1uF 0.1uF 0.1uF C704 C706 C708 C710 C712 C714 C716 C718 C720 C722 C724 C726 C756 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF CPU-353 (7/14) BOARD NO. 1-686-477-11, 12 SIU-100/100T SIU-100_CPU-353_003_7 7-12 7-12 SIU-100/100T...
  • Page 123 BD[11] D[27] BD[27] D[12] BD[12] D[28] BD[28] XBRD RD/XWR D[13] BD[13] D[29] BD[29] D[14] BD[14] D[30] BD[30] A[24] D[15] BD[15] D[31] BD[31] XBCS XBCS RB811 RB815 RB806 XR/W XR/W CPU-353 (8/14) BOARD NO. 1-686-477-11, 12 SIU-100/100T SIU-100_CPU-353_003_8 7-13 7-13 SIU-100/100T...
  • Page 124 D[13] ED[13] A[12] EA[12] D[12] ED[12] A[11] EA[11] D[11] ED[11] A[10] EA[10] D[10] ED[10] A[9] EA[9] D[9] ED[9] A[8] EA[8] D[8] ED[8] XECS RB907 RB902 XR/W RB910 ISA_BUS 005,010 CPU-353 (9/14) BOARD NO. 1-686-477-11, 12 SIU-100/100T SIU-100_CPU-353_003_9 7-14 7-14 SIU-100/100T...
  • Page 125 R1012 10k R1001 R1014 SLOT_BUS 005,009 ISA_BUS JC1020 JC1024 JC1022 007,012,013 CLK_BUS JC1004 JC1018 JC1006 JC1008 JC1010 JC1012 JC1016 JC1023 JC1014 JC1019 JC1017 JC1011 JC1005 JC1007 JC1009 JC1015 JC1013 CPU-353 (10/14) BOARD NO. 1-686-477-11, 12 SIU-100/100T SIU-100_CPU-353_003_10 7-15 7-15 SIU-100/100T...
  • Page 127 C1113 C1117 DTC144EE-TL 0.001uF 0.1uF IC1104 (2/3) TC74VHC123AFT(EL) IC1104 (1/3) TC74VHC123AFT(EL) XRES CPU_BUS 001,002,003,005,007,008,009,013 C1109 C1110 C1114 0.1uF 0.1uF 0.1uF IC1103 (3/3) CPU-353 (11/14) TC74VHC123AFT(EL) IC1104 (3/3) IC1102 (3/3) BOARD NO. 1-686-477-11, 12 TC74VHC123AFT(EL) TC74VHC123AFT(EL) SIU-100/100T SIU-100_CPU-353_003_11 7-17 7-17 SIU-100/100T...
  • Page 128 IC1324 (3/3) TC74VHC123AFT(EL) IC1327(2/4) IC1307(5/7) TC74VHC10FT(EL) TC74VHCT04AFT(EL) IC1304 (3/3) IC1305 (7/7) IC1306 (5/5) IC1307 (7/7) IC1308 (3/3) IC1309 (3/3) IC1310 (3/3) IC1312 (7/7) IC1325 (3/3) IC1326 (7/7) TC74VHC123AFT(EL) TC74VHCU04FT(EL) TC74VHC00FT(EL) TC74VHCT04AFT(EL) TC74VHC123AFT(EL) TC74VHC74FT(EL) TC74VHCT04AFT(EL) TC74VHC74FT(EL) TC74VHC123AFT(EL) TC74VHCT04AFT(EL) 7-18 7-18 SIU-100/100T...
  • Page 129 4.7k 0.1uF 0.1uF 0.1uF 100pF R1375 IC1313 (2/2) IC1314 (2/2) D1311 TLC272CPSR TLC272CPSR SVC347T-TL IC1318 SN74LV32APWR +3.3V C1355 IC1314 (1/2) 0.1uF TLC272CPSR IC1312 (3/7) TC74VHCT04AFT(EL) REFOUT IC1312 (6/7) TC74VHCT04AFT(EL) CPU-353 (12/14) BOARD NO. 1-686-477-11, 12 SIU-100/100T SIU-100_CPU-353_003_12 7-19 7-19 SIU-100/100T...
  • Page 130 IO42/F5 AUX1 IO23/C7 IO41/F6 V_SYNC_PULSE IO40/F7 ENABLE GND3 GND10 C1406 0.1uF C1403 R1415 0.1uF R1403 R1416 V_SD R1411 R1412 CLK_BUS R1413 007,010,012 R1404 UWSA INTXVIDEO REFOUT CK30M IVWS IVPP CPU-353 (13/14) BOARD NO. 1-686-477-11, 12 SIU-100/100T SIU-100_CPU-353_003_13 7-20 7-20 SIU-100/100T...
  • Page 131 WORDVIDEO L1500 18nH REF_VIDEO_IN C1503 0.1uF IC1501 SN75124NSR CN1500 D1500 WORDSYNC_IN DA221-TL FL1500 R1502 S1500 R1501 C1500 47pF R1500 C1501 10uF C1502 0.1uF IC1500 SN75121NSR FL1501 CN1501 R1503 WORDSYNC_OUT CPU-353 (14/14) BOARD NO. 1-686-477-11, 12 SIU-100/100T SIU-100_CPU-353_003_14 7-21 7-21 SIU-100/100T...
  • Page 132 ANALOG_GND ANALOG_GND +15V_B +15V_B +15V_B TB6100 R6102 R6202 C6101 C6201 100000pF 100000pF 1 2 3 C6102 C6202 C6103 C6104 C6204 C6203 100000pF 100000pF 100000pF 100000pF 100000pF 100000pF Chassis GND IF-895 (1/2) BOARD NO. 1-686-479-11, 12 SIU-100/100T SIU-100_IF-895_003_1 7-22 7-22 SIU-100/100T...
  • Page 133 C6012 SYNC COMP 0.0027uF 0.001uF 120uF 120uF C6013 C6014 C6007 R6007 6.3V 6.3V 220uF 10uF 0.0039uF 6.3V C6009 R6003 0.1uF C6008 100pF R6005 R6001 R6006 2.7k R6002 3.6k (DG) IF-895 (2/2) BOARD NO. 1-686-479-11, 12 SIU-100/100T SIU-100_IF-895_003_2 7-23 7-23 SIU-100/100T...
  • Page 134 D2473 SEC2422C SEC2422C SEC2422C SEC2422C SEC2422C SEC2422C SEC2422C SEC2422C SEC2422C SEC2422C D2408 D2416 D2424 D2432 D2440 D2448 D2456 D2464 D2472 D2474 SEC2422C SEC2422C SEC2422C SEC2422C SEC2422C SEC2422C SEC2422C SEC2422C SEC2422C SEC2422C LED-399 BOARD NO. 1-686-483-11 SIU-100/100T SIU-100_LED-399_002_1 7-24 7-24 SIU-100/100T...
  • Page 135 CN2503 VOL-1 FL2501 D2502 CL2502 02DZ20-TPH3 HP-2 D4101 CL2503 D2504 CN4154 SEL1410E VOL-2 02DZ20-TPH3 CL2504 LED_GRN D2503 02DZ20-TPH3 D2501 02DZ20-TPH3 LED_DET RV2502 20k/20k GNDGND LED-400 BOARD NO. 1-686-476-11 SIU-100/100T SIU-100_LED-400_002_1 HP-113 BOARD NO. 1-686-484-11, 12 SIU-100/100T SIU-100_HP-113_002_1 7-25 7-25 SIU-100/100T...
  • Page 136 (57/120) AD12 EA[12] 002,003,004,005,006,007,008,009,010 (117/120) 117 AGND (118/120) 118 (58/120) AD13 EA[13] 002,003,004,005,006,007,008,009,010 AGND (59/120) AD14 EA[14] 002,003,004,005,006,007,008,009,010 (119/120) 119 AGND (60/120) AD15 EA[15] 002,003,004,005,006,007,008,009,010 (120/120) 120 AGND GND-2 MB-983 (1/11) BOARD NO. 1-686-478-11, 12 SIU-100/100T SIU-100_MB-983_002_1 7-26 7-26 SIU-100/100T...
  • Page 137 (57/120) AD12 EA[12] 001,003,004,005,006,007,008,009,010 (117/120) 117 AGND (58/120) AD13 EA[13] 001,003,004,005,006,007,008,009,010 (118/120) 118 AGND (59/120) AD14 EA[14] 001,003,004,005,006,007,008,009,010 (119/120) 119 AGND (60/120) AD15 EA[15] 001,003,004,005,006,007,008,009,010 (120/120) 120 AGND GND-2 MB-983 (2/11) BOARD NO. 1-686-478-11, 12 SIU-100/100T SIU-100_MB-983_002_2 7-27 7-27 SIU-100/100T...
  • Page 138 (57/120) AD12 EA[12] 001,002,004,005,006,007,008,009,010 (117/120) 117 AGND (58/120) AD13 EA[13] 001,002,004,005,006,007,008,009,010 (118/120) 118 AGND (59/120) AD14 EA[14] 001,002,004,005,006,007,008,009,010 (119/120) 119 AGND (60/120) AD15 EA[15] 001,002,004,005,006,007,008,009,010 (120/120) 120 AGND GND-2 MB-983 (3/11) BOARD NO. 1-686-478-11, 12 SIU-100/100T SIU-100_MB-983_002_3 7-28 7-28 SIU-100/100T...
  • Page 139 (57/120) AD12 EA[12] 001,002,003,005,006,007,008,009,010 (117/120) 117 AGND (58/120) AD13 EA[13] 001,002,003,005,006,007,008,009,010 (118/120) 118 AGND (59/120) AD14 EA[14] 001,002,003,005,006,007,008,009,010 (119/120) 119 AGND (60/120) AD15 EA[15] 001,002,003,005,006,007,008,009,010 (120/120) 120 AGND GND-2 MB-983 (4/11) BOARD NO. 1-686-478-11, 12 SIU-100/100T SIU-100_MB-983_002_4 7-29 7-29 SIU-100/100T...
  • Page 140 (57/120) AD12 EA[12] 001,002,003,004,006,007,008,009,010 (117/120) 117 AGND (58/120) AD13 EA[13] 001,002,003,004,006,007,008,009,010 (118/120) 118 AGND (59/120) AD14 EA[14] 001,002,003,004,006,007,008,009,010 (119/120) 119 AGND (60/120) AD15 EA[15] 001,002,003,004,006,007,008,009,010 (120/120) 120 AGND GND-2 MB-983 (5/11) BOARD NO. 1-686-478-11, 12 SIU-100/100T SIU-100_MB-983_002_5 7-30 7-30 SIU-100/100T...
  • Page 141 (57/120) AD12 EA[12] 001,002,003,004,005,007,008,009,010 (117/120) 117 AGND (58/120) AD13 EA[13] 001,002,003,004,005,007,008,009,010 (118/120) 118 AGND (59/120) AD14 EA[14] 001,002,003,004,005,007,008,009,010 (119/120) 119 AGND (60/120) AD15 EA[15] 001,002,003,004,005,007,008,009,010 (120/120) 120 AGND GND-2 MB-983 (6/11) BOARD NO. 1-686-478-11, 12 SIU-100/100T SIU-100_MB-983_002_6 7-31 7-31 SIU-100/100T...
  • Page 142 (57/120) AD12 EA[12] 001,002,003,004,005,006,008,009,010 (117/120) 117 AGND (58/120) AD13 EA[13] 001,002,003,004,005,006,008,009,010 (118/120) 118 AGND (59/120) AD14 EA[14] 001,002,003,004,005,006,008,009,010 (119/120) 119 AGND (120/120) 120 (60/120) AD15 EA[15] 001,002,003,004,005,006,008,009,010 AGND GND-2 MB-983 (7/11) BOARD NO. 1-686-478-11, 12 SIU-100/100T SIU-100_MB-983_002_7 7-32 7-32 SIU-100/100T...
  • Page 143 (57/120) AD12 EA[12] 001,002,003,004,005,006,007,009,010 (117/120) 117 AGND (58/120) AD13 EA[13] 001,002,003,004,005,006,007,009,010 (118/120) 118 AGND (59/120) AD14 EA[14] (119/120) 119 AGND 001,002,003,004,005,006,007,009,010 (60/120) AD15 EA[15] 001,002,003,004,005,006,007,009,010 (120/120) 120 AGND GND-2 MB-983 (8/11) BOARD NO. 1-686-478-11, 12 SIU-100/100T SIU-100_MB-983_002_8 7-33 7-33 SIU-100/100T...
  • Page 144 MB-983 (9/11) MB-983 (9/11) CN3012 +15V +3.3V -15V CN3011 CPU_SLOT MB-983 (9/11) BOARD NO. 1-686-478-11, 12 SIU-100/100T SIU-100_MB-983_002_9 7-34 7-34 SIU-100/100T...
  • Page 145 001,002,003,004,005,006,007,008,009 EA[18] 001,002,003,004,005,006,007,008,009 XEREADY 001,002,003,004,005,006,007,008,009 EA[19] 001,002,003,004,005,006,007,008,009 XEINT 001,002,003,004,005,006,007,008,009 EA[20] 001,002,003,004,005,006,007,008,009 XESBHE 001,002,003,004,005,006,007,008,009 EA[21] 001,002,003,004,005,006,007,008,009 XEMEMCS16 001,002,003,004,005,006,007,008,009 EA[22] 001,002,003,004,005,006,007,008,009,011 XERESET 001,002,003,004,005,006,007,008,009 XEPD N.C. 001,002,003,004,005,006,007,008,009 XEMUTE RB3015 RB3016 RB3031 RB3032 MB-983 (10/11) BOARD NO. 1-686-478-11, 12 SIU-100/100T SIU-100_MB-983_002_10 7-35 7-35 SIU-100/100T...
  • Page 146 +3.3V +15V FL3005 +15V CN3015 -15V +15VA ERROR1 ERROR1 FL3006 ERROR2 ERROR2 ERROR3 ERROR3 ERROR4 ERROR4 ERROR5 ERROR5 ERROR6 ERROR6 FL3007 ERROR7 ERROR7 ERROR8 ERROR8 -15V FL3008 GND-2 -15VA MB-983 (11/11) BOARD NO. 1-686-478-11, 12 SIU-100/100T SIU-100_MB-983_002_11 7-36 7-36 SIU-100/100T...
  • Page 147 CN2001 CN2002 HN009 FLAT WIRE LED-399 (27P) CN2302 HN010 CN2501 HP-1 HP-1 CP-383 VOL-1 VOL-1 HP-113 HP-2 HP-2 VOL-2 VOL-2 -400 -400 POWER SW POWER SW Frame Wiring POWER UNIT (A) POWER UNIT (B) (For SIU-100T) SIU-100/100T 7-37 7-37 SIU-100/100T...
  • Page 148 (1/2) 100uF 0.1uF NJM2068M-D-TE2 PHANTOM2 C179 +5V_D 2.2uF DGND AGND PHANTOM1 Q107 D103 1SS352-TPH3 DTC123JE-TL +5V_D R192 R190 2.2k GAIN2 C176 10uF D105 CL-270D-C-TS C174 2.2uF DGND Q113 DTC123JE-TL DGND ADC-46 (1/7) BOARD NO. 1-686-488-11 DMBK-S101 DMBK-S101_ADC-46_004_1 7-38 7-38 SIU-100/100T...
  • Page 149 (1/2) 100uF NJM2068M-D-TE2 0.1uF PHANTOM4 C279 +5V_D 2.2uF DGND AGND PHANTOM3 D203 +5V_D Q207 1SS352-TPH3 DTC123JE-TL R290 R292 2.2k GAIN4 C276 10uF D205 CL-270D-C-TS C274 2.2uF Q213 DGND DTC123JE-TL DGND ADC-46 (2/7) BOARD NO. 1-686-488-11 DMBK-S101 DMBK-S101_ADC-46_004_2 7-39 7-39 SIU-100/100T...
  • Page 150 R374 100uF 0.1uF PHANTOM6 NJM2068M-D-TE2 C379 2.2uF DGND +5V_D AGND PHANTOM5 D303 +5V_D 1SS352-TPH3 Q307 DTC123JE-TL R390 R392 2.2k C376 10uF GAIN6 D305 CL-270D-C-TS Q313 C374 2.2uF DTC123JE-TL DGND DGND ADC-46 (3/7) BOARD NO. 1-686-488-11 DMBK-S101 DMBK-S101_ADC-46_004_3 7-40 7-40 SIU-100/100T...
  • Page 151 R474 100uF NJM2068M-D-TE2 0.1uF PHANTOM8 C479 +5V_D AGND 2.2uF DGND PHANTOM7 D403 Q407 1SS352-TPH3 DTC123JE-TL +5V_D R492 2.2k C476 R490 10uF GAIN8 D405 CL-270D-C-TS C474 2.2uF DGND Q413 DTC123JE-TL DGND ADC-46 (4/7) BOARD NO. 1-686-488-11 DMBK-S101 DMBK-S101_ADC-46_004_4 7-41 7-41 SIU-100/100T...
  • Page 152 C505 C509 R504 C508 C504 47uF 47uF R503 220k FREQ 0.001uF 0.22uF PGND C507 47uF C503 C501 C502 0.47uF R505 C500 4.7k 470uF R500 R507 470k C506 0.0022uF R506 DGND ADC-46 (5/7) BOARD NO. 1-686-488-11 DMBK-S101 DMBK-S101_ADC-46_004_5 7-42 7-42 SIU-100/100T...
  • Page 153 C612 PHANTOM7 0.1uF 0.1uF PAD8 GAIN8 PHANTOM8 GAINDATA3V4 SDATAOUT1 001,007 SDATAOUT2 002,007 R606 R605 4.7k 4.7k SDATAOUT3 003,007 SDATAOUT4 004,007 IC602 XC1701LPD8C-MICPREV1.1 OE/RESET DATA ADC-46 (6/7) VCC1 VCC2 DATA BOARD NO. 1-686-488-11 IC603 XC17S50AV08C DMBK-S101 RESET/OE DMBK-S101_ADC-46_004_6 7-43 7-43 SIU-100/100T...
  • Page 154 C717 C721 0.1uF 0.1uF IC709 (4/5) SN74LV125APWR GAINDATA4 GAINDATA3V4 C700 C701 C702 C703 C709 C710 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF DGND DGND ADC-46 (7/7) DGND DGND DGND DGND DGND DGND DGND BOARD NO. 1-686-488-11 DMBK-S101 DMBK-S101_ADC-46_004_7 7-44 7-44 SIU-100/100T...
  • Page 155 100uH 100uH 100k 100k R102 R104 4.7k 2.2k C/STBY C105 R100 R101 0.1uF CN-2363 BOARD NO. 1-686-486-11 SIU-RM101 C100 C101 C104 D100 C106 C112 C113 C114 C115 220uF 220uF 220uF 220uF 100uF 0.1uF EA30QS04-TE16F2 2200uF 0.1uF SIU-RM101_CN-2363_003_1 7-45 7-45 SIU-100/100T...
  • Page 156 1CLR IC309 -KEYINT EPM7032-KEY-V1.0 SCANCLK 2CLR -RESET R308 -CS_EPROM -XRD FL308 R309 +4.5045V R313 C300 4.7k Set to detect 100uF +4.662V as +4.2V -RESET R310 CPU-354 (1/3) S300 IC302 RN5VD42AA-TL BOARD NO. 1-686-485-11 SIU-RM101 C303 0.1uF SIU-RM101_CPU-354_002_1 7-46 7-46 SIU-100/100T...
  • Page 157 R409 Q409 R425 Q425 2SD1802FAS-TL 2SD1802FAS-TL C415 C435 100pF 100pF -3CH-1 -8CH-2 R410 Q410 R426 Q426 2SD1802FAS-TL 2SD1802FAS-TL C416 C436 100pF 100pF -3CH-2 -8CH-3 R411 Q411 R427 Q427 CPU-354 (2/3) 2SD1802FAS-TL 2SD1802FAS-TL BOARD NO. 1-686-485-11 SIU-RM101 SIU-RM101_CPU-354_002_2 7-47 7-47 SIU-100/100T...
  • Page 158 C511 C512 C513 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF 0.001uF -LEDDIS R502 R505 R508 R511 R514 R517 R520 R523 4.7k 4.7k 4.7k 4.7k 4.7k 4.7k 4.7k 4.7k -RPG0 -KRD0 CPU-354 (3/3) BOARD NO. 1-686-485-11 SIU-RM101 SIU-RM101_CPU-354_002_3 7-48 7-48 SIU-100/100T...
  • Page 159 -SW6 -SW6 -SW7 -SW7 -SW8 -SW8 DIG1K DIG2K DIG3K DIG1K DIG2K DIG3K DIG1K DIG2K DIG3K DIG1K DIG2K DIG3K DIG1K DIG2K DIG3K DIG1K DIG2K DIG3K DIG1K DIG2K DIG3K DIG1K DIG2K DIG3K FP-137 BOARD NO. 1-686-487-11, 12 SIU-RM101 SIU-RM101_FP-137_002_1 7-49 7-49 SIU-100/100T...
  • Page 160 Frame Wiring Frame Wiring CN-2363 CPU-354 FP-137 REMOTE REMOTE MIDI HN002 AC ADAPTER FLEXIBLE DC JACK (ACCESSORY) FLAT CABLE HN001 FLEXIBLE FLAT CABLE FLEXIBLE FLAT CABLE HN003 POWER SWITCH Frame Wiring SIU-RM101 7-50 7-50 SIU-100/100T...
  • Page 161 For SIU-100/100T SAFETY CHECK-OUT After correcting the original service problem, perform the following safety checks before releasing the set to the customer : Check the metal trim, “metallized” knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below.
  • Page 162 Printed in Japan SIU-100 (SY) Sony Corporation 2003. 7 08 SIU-100T (SY) E ©2003 9-976-912-01...

This manual is also suitable for:

Siu-100tDmbk-s101Siu-rm101

Table of Contents