Page 2
LENOVO Documents statement: This document is intended for use by qualified service personnel only. The documents only are used for service reference.
LENOVO 1. Product Figures 1-1. Exploded view X1101 X101 26M Crystals Damage caused by failure:: U501 Power Management Can not boot;WIFI、 GPS、 BT、 Damage caused by failure: FM test fail large currents;does not boot; U106 RF-TR U108 BBIC Damage caused by failure:...
Page 6
LENOVO J802 USB Connector J801 Headphone Jack Damage caused by failure: Doesn’t charge,data transmit Damage caused by failure: Headphones silent; not receive FM J1003 Front camera Damage caused by failure: J601 Back camera Cannot take photo Damage caused by failure:...
LENOVO 1-2. Product Main Function Support Camera Music player Support T-Flash card Support WIFI 4.0" WVGA LCD Support GSM850&GSM900&DCS1800&PCS1900&WCDMA900&WCDMA210 Network Support Bluetooth Support FM radio Support dual SIM card Support G-sensor Support GPS 1-3. General Specificatio PCS1900 1850~1910 1930~1990 512~810 80 MHz 270.833 kbps...
LENOVO 2. Block Diagrams 2-1. System Diagrams RF-TR Charger 5V IN RF-PA Battery SIM 1/SIM Audio_PA Speak USB DM/DP T-FLASH URAT TX/RX Camera Bluetoot 3.5MM WIFI IC Earphoen Receiver FM Radio ROM+RAM Side Health WVGA LCD TX PA Remark:FM/GPS/WIFI/BT to Four in Chip;...
LENOVO GPU models for SGX still 544. Typical application diagram is shown in nether figure Application Diagram of MT6582 2-2. Power Management Diagrams...
LENOVO 3. Flow Chart of Troubleshooting 3-1.Baseband 3-1-1. Phone does not start up troubleshooting Power-on Sequence and Protection Logic: The PMU handles the powering ON and OFF of the handset. There are three ways to power-on the handset system : ①...
Page 12
LENOVO Troubleshooting flow chart Main related component: BBIC(U108),NAND+SDRAM(U401), XTAL CRYSTAL(X101),RF-TR(U201), PMIC(U501),Power button. Power ON/OFF and download circuit From BBIC POWER KEY MINI USB CIRCUIT...
Page 13
LENOVO Download troubleshooting Main related component: BBIC(U108),NAND+SDRAM(U401),RF-TR(U106), XTAL CRYSTAL(X101), MINI USB(J802). Download fault Check circuit component UART connection fault visually .soldered again or replace damaged component Press phones power key Soldered again or replace Observe the current BBIC Current is large ≤20MA...
LENOVO SIM CIRCUIT SIM1&SIM2 From BBIC From BBIC From BBIC From BBIC 3-1-3. MIC troubleshooting Troubleshooting flow chart Main related component: BBIC(U108),MIC...
Page 16
LENOVO Microphone does not work Check MIC circuit Soldered again or replace component visually damaged component OK? Check microphone Soldered again or replace damaged component OK? Is the bias Voltage 2.4V Check BBIC Soldered again or measured from MICP replace...
Page 17
LENOVO MIC circuit FromPMIC From MIC To BBIC...
LENOVO 3-1-4. T-Flash troubleshooting Troubleshooting flow chart Main related component: BBIC(U108),T-FLASH CONNECTOR(J603). Phone does not read T-Flash Check T-Flash card Replace T-Flash Check T-flash connector Solder again or replace solder joints and spring IS T-Flash working NOW contacts is OK...
LENOVO T-Flash circuit To BBIC Voltage From U502 3-1-5. Speaker troubleshooting Speaker circuit From BBIC To speaker Troubleshooting flow chart Main related component: BBIC(U108),SPEAKER...
Page 20
LENOVO Speaker does not work Check Speaker Replace Speaker Check Audio circuit Solder again or replace component visually The damaged component OK? Measure Audio PA work voltage(VBAT) Check PA VBAT circuit Normal:3.6-4.2V Check BBIC Soldered Measure Audio PA enable again or replace signal(AUDIO-EN)Normal:2.8V...
LENOVO 3-1-6. Receiver troubleshooting Troubleshooting flow chart Main related component: BBIC(U108),Receiver Earpiece does not work Check Earpiece circuit Soldered again or replace component visually damaged component OK? Check earpiece Soldered again or replace IS earpiece working now? Check BBIC Soldered again or...
LENOVO Receiver circuit From BBIC To receiver 3-1-7. Vibra troubleshooting Troubleshooting flow chart Main related component: BBIC,MOTOR,KB board ConnectorJ1201 Vibra circuit From PMIC To VIB...
Page 23
LENOVO Vibra Fault Replace Motor Check Moto OK? Soldered again or replace Check Moto circuit damaged component OK? component visually Measure Motor working Check BBIC Soldered again or Voltage:VBAT mormal replace :3.6-4.2V Check KB Connector Soldered again or replace soldered ok?...
LENOVO 3-1-8. Camera troubleshooting Troubleshooting flow chart Main related component: BBIC(U108),NOR+UTRAM(U401),CAMERA MODULE. camera module Fix camera properly Camera does not work properly fixed IS camera working now? Check camera module OK? Replace damaged component Soldered again or replace Check camera connector solder...
Page 25
LENOVO Camera circuit Front Camera circuit From BBIC...
LENOVO 3-1-9. FM radio troubleshooting Troubleshooting flow chart Main related component: BBIC(U108),earphone jack(J801),FM radio(J1102) Check FM radio circuit Soldered again or replace FM radio does not work component Ok damaged component ok? Check FM antenna and Replace damaged component earphone OK?
Page 27
LENOVO FM Circuit From earphone HEADGND ANT IN...
LENOVO 3-1-10. Display troubleshooting Troubleshooting flow chart Main related component: BBIC(U108),EMI(F701-F702),LCD. display Check circuit Soldered again or replace doesnot work component Ok damaged component ok? Soldered again or replace Check soldered LCD ,IS FM working now? status of LCD Backlight fault...
Page 29
LENOVO Display Circuit LCD Connector circuit From BBIC Backlight signal From LED driver LCD backlight circuit To LCD PAD Backlight EN From BBIC...
LENOVO 3-1-11. Bluetooth WIFI GPS troubleshooting Troubleshooting flow chart Main related component: BBIC(U108) ,BT/WIFI/GPS MODEM(J1102),The Clock signal provided by the CPU; BT/WIFI/GPS/FM check BBIC or Check CLK signal All the function are not Crystal oscillator is ok Work? Soldered again...
Page 31
LENOVO RF-filter(WIFI/BT/GPS) TO U1102 BT/WIFI/GPS ANT...
Page 32
LENOVO 3-1-12. Side health Troubleshooting Keyboard circuit From BBIC Troubleshooting flow chart Main related component: BBIC(U108) and keypad FPC...
Page 33
LENOVO Check keypad Cleaning keypad Keyboard failure normal visually Replace dome sheet Check keypad dome keypad working now? sheet visually One or more row/column is not whole row/column is not working? working? Soldered again or Check keypad FPC Check keypad FPC...
LENOVO 3-1-13. Charge troubleshooting Troubleshooting flow chart Main related component: BBIC(U108), USB(J802),MOSFET(U502). does not charge Check whether the Soldered again or replace normal charger damaged component OK? Soldered again or replace Check charger IC is charger IC working properly Soldered again or replace...
LENOVO 3.2 RF 3-2-1.GSM/DCS RX troubleshooting Troubleshooting flow chart BBIC(U108) XTAL CRYSTAL Main related component: (X101),RF-TR(U201),RF-PA(U101),RX FILTER(U103) Soldered again or GSM/DCS/PCS RX does not Check RX replace circuit Check inside place antenna is one feed and one Trim or replace antenna...
Page 37
LENOVO 3-2-2.GSM/DCS TX Part Troubleshooting flow chart BBIC(U108) , XTAL CRYSTAL Main related component: (X101),RF-TR(U106),RF-PA(U102) Soldered again or GSM/DCS/PCS TX does not work Check TX circuit replace component visually Check antenna matching Trim or replace antenna component Soldered again or replace...
Page 38
LENOVO DCS1800 TX GSM900 TX TX signal From RF- transceiver transceiver circuit GSM900 TX DCS1800 TX RX signal From RF-Switch...
LENOVO 4-2. RF part 4-2-1 RF PA(U101) Features 3.2 to 4.2V low voltage bias power supply Support for WCDMA/HSDPA/HSUPA The linear output power to 28 DBM 45% efficient (28 DBM) Provide three gain modes For using DC/DC power supply and optimization...
LENOVO 5. Test Instructions Press the volume down button and power button to enter the engineering test mode, select "full test" into automatic test pattern: 1. ALS/PS test; 17. Battery & Charge test; 2. Touch Panel test; 18. Version test;...
LENOVO 7. Warnings and cautions Warnings If the device can be installed in a vehicle, Care must be taken on installation in vehicles fitted with. Electronic engine management systems and anti-skid braking systems. Under certain fault conditions, Emitted rf energy can affect their operation. If necessary, Consult the vehicle dealer/manufacturer to determine the immunity of vehicle electronic systems to RF energy.
Page 70
LENOVO subject to interference. Before making any test connections, Make sure you have switched off all equipment. Cautions Servicing and alignment must be undertaken by qualified personnel only. Ensure all work is carried out at an anti-static workstation and that an anti-static wrist strap is worn.
Page 71
LENOVO during shipping and handling outside any ESD Protected Area (EPA). Every repair action involving opening the product or handling the product components must be done under ESD protection. ESD protected spare part packages MUST NOT be opened/closed out of...