2. Be careful in handling ICs. Some ICs such as MOS type are so fragile that they can be damaged by electrostatic induction. RS-P90/EW5...
Page 3
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual. RS-P90/EW5...
• Screw adjacent to mark on the product are used for disassembly. • For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.) 2.1 PACKING RS-P90/EW5...
Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST". Large size SCH diagram CONNECTOR PCB Guide page Detailed page DSP UNIT Consists of DSP PCB CONNECTOR PCB > CN3201 CN2101 FUSE FUSE > RS-P90/EW5...
Page 15
No differentiation is made between chip capacitors and 0.022 R022 discrete capacitors. The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. > CN2401 RS-P90/EW5...
For further information for CN2402 respective destinations, be sure to check with the schematic dia- CN2403 gram. 2.Viewpoint of PCB diagrams Capacitor Connector SIDE A SIDE B P.C.Board Chip Part CN2101 CN3201 CN513 IP-BUS IN SUBWOOFE DIGITAL IN LOW OUT RS-P90/EW5...
Page 39
SIDE A CN2401 POWER SUPPLY SUBWOOFER OUT MID OUT LOW OUT HIGH OUT RS-P90/EW5...
Q 802 (B,178,176) Transistor UMZ1N IC 801 (A,171,156) IC AN8011S IC 851 (A,201,111) IC AN8011S Q 803 (B,195,166) Transistor 2SJ529S Q 804 (B,177,168) Transistor 2SJ529S IC 896 (A,140,110) IC TA79L12F Q 810 (A,199,230) Transistor 2SK1485 IC 897 (A,135,110) IC TA79L12F RS-P90/EW5...
Page 48
(A,80,59) Diode DAN202U R 128 (A,114,42) RS1/16S222J L 310 (A,75,21) Inductor LCTC1R8K2125 R 129 (A,109,42) RS1/16S222J R 130 (A,104,42) RS1/16S222J L 316 (B,65,29) Inductor LCTC120K2125 L 651 (A,18,81) Inductor LCTC1R8K2125 R 131 (A,128,43) RS1/16S222J L 701 (B,51,24) Inductor CTF1410 RS-P90/EW5...
Page 49
R 200 (A,123,110) RN1/10SE4700D R 659 (A,18,90) RS1/16S222J R 201 (A,123,108) RN1/10SE4700D R 660 (A,18,89) RS1/16S222J R 202 (A,115,114) RN1/10SE4701D R 661 (A,26,84) RS1/16S101J R 203 (A,120,103) RN1/10SE4701D R 662 (A,34,112) RS1/16S103J R 204 (B,120,108) RN1/10SC22R0D R 663 (A,18,92) RS1/16S103J RS-P90/EW5...
Page 50
(A,66,205) 10 µF/50 V CCH1543 R 851 (A,203,102) RS1/16S4301D C 113 (A,116,213) 10 µF/50 V CCH1543 R 853 (A,168,107) RS1/16S4302D C 114 (A,116,205) 10 µF/50 V CCH1543 R 854 (B,167,129) RS1/16S1501D C 115 (A,106,213) 10 µF/50 V CCH1543 R 855 (A,206,102) RS1/16S2400D RS-P90/EW5...
Page 51
C 195 (A,86,125) CCSQCH470J50 C 272 (A,82,93) CCSQCH101J50 C 196 (B,91,121) CKSQYB104K50 C 273 (A,84,93) CCSQCH102J50 C 197 (A,86,165) CCSQCH220J50 C 274 (A,89,93) CCSQCH390J50 C 198 (B,86,157) CKSQYB104K50 C 275 (A,91,93) CCSQCH101J50 C 199 (A,91,165) CCSQCH220J50 C 276 (A,93,93) CCSQCH102J50 RS-P90/EW5...
Page 52
(A,169,203) 100 µF/16 V CCH1702 C 854 (A,154,114) CKSRYB104K50 C 945 (A,169,215) 100 µF/16 V CCH1702 C 855 (A,158,127) CEHAZL101M25 C 946 (B,176,211) CKSRYB104K50 C 856 (A,158,119) CEHAZL101M25 C 971 (B,56,24) CCSCH101J50 C 857 (B,165,124) CKSRYB104K50 C 981 (A,79,52) CEAT470M35 RS-P90/EW5...
Page 53
(A,162,19) IC MSM56V16160F8TKFM L 3011 (A,25,95) Chip Ferrite Bead CTF1399 IC 4601 (A,166,99) IC ADSP-21065LCS240S1 L 3012 (A,25,100) Chip Ferrite Bead CTF1399 IC 4751 (A,196,92) IC TC74LCX541FTS1 L 3013 (A,53,65) Chip Ferrite Bead CTF1399 IC 4803 (A,177,132) IC MSM56V16160F8TKFM RS-P90/EW5...
Page 54
R 2213 (B,84,103) RS1/16S0R0J R 2503 (A,117,153) RN1/10SE1801D R 2214 (A,87,96) RS1/16S101J R 2504 (A,126,151) RN1/10SE1801D R 2215 (A,87,98) RS1/16S103J R 2505 (A,71,153) RN1/10SE1801D R 2216 (B,83,94) RS1/16S0R0J R 2506 (A,81,151) RN1/10SE1801D R 2218 (B,81,94) RS1/16S0R0J R 2507 (A,86,153) RN1/10SE1801D RS-P90/EW5...
Page 55
R 3036 (A,89,88) RN1/16SC47R0D R 4011 (A,99,68) RS1/16S47R0D R 3037 (A,48,73) RN1/16SC47R0D R 4012 (A,97,68) RS1/16S47R0D R 3039 (B,47,61) RN1/16SC47R0D R 4013 (B,100,66) RS1/16S103J R 3040 (A,22,87) RN1/16SC47R0D R 4014 (B,98,66) RS1/16S103J R 3041 (A,22,89) RN1/16SC47R0D R 4015 (B,96,66) RS1/16S103J RS-P90/EW5...
Page 56
R 4086 (A,115,35) RS1/16S47R0D R 4311 (A,167,69) RN1/16SC47R0D R 4087 (A,79,30) RS1/16S47R0D R 4312 (B,172,61) RS1/16S103J R 4088 (A,113,30) RS1/16S0R0J R 4313 (B,168,61) RS1/16S103J R 4089 (A,112,30) RS1/16S0R0J R 4314 (B,166,61) RS1/16S103J R 4090 (A,110,30) RS1/16S0R0J R 4315 (B,164,61) RS1/16S103J RS-P90/EW5...
Page 57
R 4389 (A,180,30) RS1/16S0R0J R 4614 (B,167,88) RS1/16S103J R 4390 (A,179,30) RS1/16S0R0J R 4615 (B,169,84) RS1/16S103J R 4391 (A,177,30) RS1/16S0R0J R 4616 (A,169,80) RN1/16SC47R0D R 4392 (A,176,30) RS1/16S0R0J R 4617 (B,173,88) RS1/16S103J R 4393 (A,173,30) RS1/16S47R0D R 4618 (B,171,84) RS1/16S103J RS-P90/EW5...
Page 58
R 4691 (A,159,118) RS1/16S0R0J CAPACITORS R 4692 (A,161,118) RS1/16S0R0J R 4693 (A,164,118) RS1/16S47R0D C 2001 (A,24,78) 47 µF/25 V CCH1643 R 4694 (A,165,121) RS1/16S47R0D C 2002 (B,20,79) CKSRYB104K16 R 4695 (A,166,118) RS1/16S47R0D C 2003 (A,11,73) CKSRYB104K16 R 4696 (A,167,121) RS1/16S47R0D RS-P90/EW5...
Page 59
C 2352 (B,120,141) CKSQYB104K50 C 2535 (B,86,153) CCSQCH221J50 C 2353 (B,78,141) CKSQYB104K50 C 2536 (A,97,151) CCSQCH221J50 C 2354 (B,89,141) CKSQYB104K50 C 2537 (A,38,153) CCSQCH221J50 C 2355 (B,48,141) CKSQYB104K50 C 2538 (A,51,151) CCSQCH221J50 C 2356 (B,57,141) CKSQYB104K50 C 2539 (B,55,153) CCSQCH221J50 RS-P90/EW5...
Page 60
C 3043 (A,26,92) CKSRYB104K16 C 4029 (B,105,39) CKSRYB103K50 C 3044 (A,24,92) CKSRYB104K16 C 4030 (B,102,39) CKSRYB103K50 C 3045 (A,26,97) CKSRYB104K16 C 4032 (B,98,39) CKSRYB103K50 C 3046 (A,24,97) CKSRYB104K16 C 4034 (B,94,39) CKSRYB103K50 C 3047 (A,54,62) CKSRYB104K16 C 4035 (B,92,39) CKSRYB103K50 RS-P90/EW5...
Page 61
C 4337 (B,155,39) CKSRYB103K50 C 4641 (B,188,126) CKSRYB104K16 C 4338 (B,181,38) CKSRYB102K50 C 4642 (B,180,132) CKSRYB104K16 C 4339 (B,192,42) CKSRYB104K16 C 4643 (B,170,132) CKSRYB104K16 C 4340 (B,192,38) CKSRYB104K16 C 4644 (B,167,131) CKSRYB104K16 C 4341 (B,202,51) CKSRYB104K16 C 4645 (B,196,110) CKSRYB104K16 RS-P90/EW5...
Page 62
C 4903 (B,130,81) CKSRYB104K16 C 4904 (A,130,80) CASA470M10 C 4905 (A,114,81) CKSRYB104K16 C 4906 (A,123,87) CCSRCH180J50 C 4907 (A,112,86) CCSRCH220D50 C 4912 (A,124,79) CKSRYB104K16 C 4951 (A,9,53) CKSRYB104K16 C 4952 (A,9,51) CKSRYB104K16 C 4954 (B,13,17) CKSRYB104K16 C 4955 (B,14,47) CKSRYB104K16 RS-P90/EW5...
(Waveform Confirmation for Adjustment) Waveform confirmation is required since the waveform may be deformed according to the type of probe to be used when adjusting master clock. The waveform is basically a rectangular wave of 0 --- 3.3 V (24.576 MHz). RS-P90/EW5...
7. GENERAL INFORMATION 7.1 DIAGNOSIS 7.1.1 DISASSEMBLY Removing the Panel (Fig.1) Panel Remove the six screws and then remove the two Panels. Panel Fig.1 Removing the Holder (Fig.2) Holder Remove the screw and then remove the Holder. Fig.2 RS-P90/EW5...
Page 66
Disconnect the five connectors. Remove the three screws and then remove the DSP Unit. DSP Unit Fig.3 Removing the Control Unit (Fig.4) Control Unit Straighten the tabs at four locations indicated. Remove the three screws and then remove the Control Unit. Fig.4 RS-P90/EW5...
Page 69
MUTEA MUTEB LRCKOB LRCKIB Input Digital Output Digital BCKOB Serial Re Sampler BCKIB De Emphasis and Decimation Serial SDOUTB Port Filter Port Interpolation Filters SDINB TDMIB sOUT Rate DGND Estimator VDD18 (2) RDYB VDD33 (2) RATIOB DGND RCKIB REGEN RS-P90/EW5...
Page 76
DIT reset input DIR unlock information input DIR audio/data select output DIR emphasis information output DSP error information input Not used PLD config strobe output Not used 54,55 Power indicator LED control output 57-60 Not used PLD config strobe output RS-P90/EW5...
Page 77
AD translation reference voltage AVCC SIN4 PLD serial data input SOUT4 PLD serial data output PEG169A Format Meaning CMOS N ch open drain HA12241FP TC7SET04FUS1 -BUS +BUS BIAS IN A DRIVER OUTPUT (current) OUT Y RECEIVER OUTPUT S-812C33AMC-C2N R out Reference Voltage RS-P90/EW5...
PW lamp on and off Mute OFF(Pin42:L) DSPPW on (Pin40:H) Error DSP error Pin51:H DSP initialization failure PLD,DSP initialization About 3 seconds Pin48=H Un lock Pin48:H? Mute off (Pin42:L) DIT reset Pin47=L Pin16:Low and Pin15:Low Bup or Acc off RS-P90/EW5...
Optical input (blue) Blue/white To system control terminal of the power amp (max. 300 mA 12 V DC). Clear/red To terminal always supplied Fuse holder with power regardless of (4 A) ignition switch position. Clear/black (ground) To vehicle (metal) body. RS-P90/EW5...
Page 82
Connecting the RCA input amplifier White For system remote control Blue/white Blue/white White Tweeter Power amplifier Mid range Power amplifier Woofer Power amplifier Subwoofer Power amplifier RS-P90/EW5...
Page 84
- Jigs List Name Jig No. Remarks 2-Pin Extension cable GGD1028 Control Unit (CN302) <--> DSP Unit (CN2101) 32-Pin FFC GGD1288 Control Unit (CN601) <--> DSP Unit (CN3201) RS-P90/EW5...