Table of Contents
MAINTENANCE
FUEL SYSTEM AND AIR INTAKE
FUEL TANK VENT INSPECTION
Symptoms of a restricted fuel tank vent include the
following:
• collapsing or expanding fuel tank
• hiss / rush of air when fuel tank cap is removed
• engine miss or hesitation
• loss of engine performance
• high exhaust temperatures
1. Remove the seats and the engine service panel.
2. Check the fuel tank vent line
deterioration or damage. Replace vent line if
necessary.
3. Be sure the vent line is routed properly as shown and
secured with cable tie(s).
Make sure vent line is not kinked or pinched.
4. The vent hose should route towards the driver's side
rear of the vehicle and terminate into the frame tube.
2.40
q
for signs of wear,
NOTE
THROTTLE PEDAL INSPECTION
This vehicle is equipped with Pedal Position Sensor
used to detect when the throttle pedal
released.
The throttle pedal should move freely and always return
back to its idle position when released.
Check throttle pedal periodically.
ENGINE INTAKE PRE-FILTER SERVICE
It is recommended that the engine intake pre-filter be
inspected daily. The filter should be inspected using the
following procedure:
1. The engine intake pre-filter is located just above the
right rear wheel fender.
2. Inspect the pre-filter on the outboard
w
sides. If necessary, clean with soapy water and air
dry.
CAUTION
Compressed air or high pressure hose may damage the
frog skin pre-filter on the intake.
9928491 R04 - 2017-2018 RZR XP Turbo / XP4 Turbo Service Manual
w
is pushed or
q
and inboard
© Copyright Polaris Industries Inc.
q
Chapters
Table of Contents
Troubleshooting
